Military Engineer Services Tender

Taking down old ceiling fan of any capacity/sweep after disconnecting the electric supply from any site, checking for its electrical defect and opening fans for checking of mechanical defect after dismantling of fan, carry out repair/over hauling including removing dust and grease, and cleaning of internal mechanical parts of fan with kerosene oil, checking of alignment of shaft, oiling and greasing, checking of worn out bearing and other defective parts, winding, condenser etc and re-assembling, and connecting/refixing of fans in its original position by providing new GI nut bolt, lock washer and lock/split pin complete all as specified and directed by Engr-in-charge. NOTE: (i) Replacement of defective parts other than rubber bush, split pin, nuts, olts, sprng washers, check nuts etc (as required are deemed to be included in the item rate) will be measured and paid separately under respective item as Supply only. (ii) Painting and rewinding, if required shall be measured and paid seperately

Taking down old Exhaust fans/Wall mounting fans/ Air cirulators fan of any capacity/sweep after disconnecting the electric supply from any site, checking for its electrical defect and opening fans for checking of mechanical defect after dismantling of fan, carry out repair/over hauling including removing dust and grease, and cleaning of internal mechanical parts of fan with kerosene oil, checking of alignment of shaft, oiling and greasing, checking of worn out bearing and other defective parts, winding, condenser etc and re-assembling, and connecting/refixing of fans in its original position by providing new grouting bolts, GI nut bolt, lock washer and lock/split pin including making good of disturbed surfaces complete all as specified and directed by Engr-in-charge. NOTE: (i) Replacement of defective parts other than rubber bush, split pin, nuts, olts, sprng washers, check nuts etc (as required are deemed to be included in the item rate) will be measured and paid separately under respective item as Supply only. (ii) Painting and rewinding, if required shall be measured and paid seperately

M&L for Opening Stator of Ceiling Fan 1200mm Sweep Cleaning of Parts, replacement of Unserviceable Parts as ordered, Greasing of Moveable Parts, Taking out burnt Coil, Cleaning the Segments complete and Re-winding the Same with Supper Enameled Copper Wire of same Gauge and same Weight with Insulation Paper, Varnishing and Heating, Re-assemble the same after repaired and Testing, complete all as specified and as directed . NOTE : Unserviceable Parts viz Ball Bearing, Bush, Capacitor, Blades, winding wire etc. shall be Measured and Paid separately under respective Items as mentioned here-in-before.