Hindu Religious And Charitable Endowments Tender

Labour charges for removing the old stone exsisting bothiyal nd carefully stacking the same as directed etc complete complying with standard specification and as directed by the departmental officers.(TNBP. Specification.No : 16,17 &special)

Labour charges for removing the old stone exsisting uthiram nd carefully stacking the same as directed etc complete complying with standard specification and as directed by the departmental officers.(TNBP. Specification.No : 16,17 &special)

Earthwork excavation for foundation in all soils and sub soils to full depth as may be directed except in hard rock requiring blasting inclusive of shoring shuttering, baling out water wherever necessary, refilling the foundation with excavated earth and depositing the surplus earth within compound in places shown by the departmental officers with an initial lead of 10 metre and initial lift of 2 metre and clearing and leveling the site etc., complete complying with standard specification and as directed by the departmental officers. SS20 B.(TNBP. Specification.No : 23 )

Supplying and filling in foundation, basement, etc with filling crushed stone sand (M.Sand) in layers of not more than 15 cm thick well watered, rammed and consolidated etc. complete complying with standard specification and as directed by the departmental officers. (TNBP. Specification.No : 24&25 )

Cement Concrete 1:5:10 (One of Cement, Five of crushed stone sand and Ten of hard granite broken stone jelly) using 40 mm gauge hard broken granite stone jelly for foundation including dewatering wherever necessary and laid in layers of not more than 15 cm thick well rammed, consolidated and curing etc. complete complying with standard specification and as directed by the departmental officers.(TNBP. Specification.No : 28 )

Supplying and erecting steel centering including necessary supports for plane surfaces for Reinforced Cement Concrete works such as column footings, column pedestals, plinth beams, grade beams, staircase steps, etc. which require only nominal strutting using mild steel sheets of size 90cm x 60cm and 10 BG stiffened with welded mild steel angles of size 25mm x 25mm x 3 mm for boarding, laid over silver oak joists of size 10cm x 6.5cm spaced at about 75cm centre to centre or at suitable intervals etc. complete in all floors complying with standard specifcation.and as directed by the departmental officers (TNBP. Specification.No : 72,86) (Payment for centering shall be given after the concrete is laid)

Below ground level

Above ground level

Slab

Providing and laying in position, standardised concrete Mix M-20 Grade in accordance with IS 456 using 20mm and down graded hard broken granite stone jelly for all RCC items of works with minimum cement content of 325 kg/m3 and maximum water cement ratio of 0.55, including admixture (plasticiser / super plasticiser) in recommended proportions as per IS:9103 to accelerate, retard setting of concrete, improve workability without impairing strength and durability with about (5 cu.m.) 7730 kg. of 20mm machine crushed stone jelly and with about (3.3 cu.m.) 5156 kg. of 10-12mm machine crushed stone jelly and with about (4.79 cu.m) 7670 kg. of crushed stone sand, but excluding cost of reinforcement grill and fabricating charges, centering and shuttering and also including laying, vibrating with mechanical vibrators, finishing, curing, etc. and providing fixtures like fan clamps in the RCC floor/ roof slabs wherever necessary without claiming extra, etc., complete complying with standard specification and as directed by the departmental officers. The coarse and fine aggregates to be used should comply with the requirements of IS standards. (No separate payment will be made by the Department for the excess usage of materials). (TNBP. Specification.No : 30)

Below Basement

Above Basement

Supplying, fabricating and placing in position Mild Steel / Ribbed Tor Steel grills for all RCC works as per design given including cost of steel and G.I. binding wire in all floors etc. complete complying with standard specification. (Contractor has to make his own arrangements for the supply of steel and binding wire)(TNBP. Specification.No : 86&86A)

Random Rubble masonry work with using Special mixing Lime morter 1:2 ( One of lime and two of M.sand )mix usingwith jaggery galnut as directed and using selected rough stones Bond stones in foundation and basement including simulatenous flush pointing with same mortar and including dewatering wherever necessary proper setting,curing,etc., complete complying with standard specification and as directed by the departmental officers.(TNBP. Specification.No : 35-H ) (The lime used should be sourced from Pollachi which is highly iron fortified and suitable for structural and masonry works.)

Brick Work in Cement Mortar 1:5 (one of Cement and Five of M.sand) using best quality of country bricks of size 8 3/4"x4 1/4"x 2 3/4" including neat finishing curing etc., complete complying with standard specification and as directed by the departmental officers.(TNBP. Specification.No : 31-C)

Special ceiling plastering and finishing the exposed surface of all RCC items of work such as slabs, beams, sunshades, facia, canopy slab, staircase waist slab, landing slab etc., with Cement Mortar 1:3 (One Cement and Three Plastering Sand) 10mm thick including hacking the surfaces, providing cement mortar nosing, beading for sunshades, staircases, steps, landing slabs and curing, etc., in all floors complying with standard specification and as directed by the departmental officers (TNBP. Specification.No : 52&53)

Painting two coats with approved first quality water based Exterior Emulsion over the neutiy plastered wall surface, ceiling and other new surface with one coat priming coat with approved primer including clearing preparing the surface curing in all floors including brushes etc., complete as per specification. (The make, quality ,shade and colour of paint should be got approved by the Executive Engineer before use on works.)(TNBP. Specification.No : 66&66-A )

Weathering course in brick jelly lime concrete using broken brick jelly of size 20mm uniform gauge in pure slaked lime (no crushed stone sand to be used) to the proportion of brick jelly to lime being 32:12.5 by volume and laid over the RCC roof slab in a single layer of required slope and finished by beating the concrete with wooden beaters of approved pattern, keeping the surface constantly wet by sprinkling lime jaggery water, etc., complete Complying with standard specifications. and directed by the departmental officers (The lime used should be sourced from Pollachi which is highly iron fortified and suitable for structural and masonry works.)(TNBP. Specification.No : 44 )

Finishing the top of roof with one course of machine pressed tiles of size 230mm x 230mm x 20mm of approved quality set in lime Mortar 1:1.5 (One of lime and one & half Crushed stone sand)12mm thick mixed with water proofing compound conforming to ISS at 2% by weight of cement used and the joints pointed neatly to full depth of tiles with the same cement mortar mixed with red oxide and water proofing compound including curing etc., complete complying with standard specification and as directed by the departmental officers. the lime used should be somes from pollachi (TNBP. Specification.No : 44-H)

Supply of cut stone blocks roughly dressed, shaped with required quality and size upto 5 feet(1'x1'x5') including cost and conveyance and handling charges etc., complete complying with standard specification.and as directed by the departmental officers(TNBP. Specification.No : special)

Supply of cut stone blocks roughly dressed, shaped with required quality and size upto 10 feet(1'6"x1'6"x10') including cost and conveyance and handling charges etc., complete complying with standard specification.and as directed by the departmental officers(TNBP. Specification.No : special)

Supplying & Paving flooring with cut stone of size 600 mm X 600 mm and another sizes suitable for site conditions with machine cut edges and not less than 100mm thick one side fully dressed and fully dressed as directed by the departmental officers,and set in special grinding Lime morter 1:1.5 ( One of lime and One and Half of M.sand )using freshly burnt lime (cao not less than 75 %)with jaggaery,galnut as directed and pointing with special grinding Lime morter 1:1.5 ( One of lime and One and Half of M.sand ) including cost and conveyance of all materials etc., complete Complying with standard specifications. and directed by the departmental officers (The lime used should be sourced from Pollachi which is highly iron fortified and suitable for structural and masonry works.)(TNBP. Specification.No : 4&35 and special )

Labour Charges for old Stone fully dressing and Fixing pavukkal charges including pointing with special grinding lime mortoar 1:1.5 and all lifting charges etc.complete complying with standard specifications and as directed by the departmental officers.(TNBP. Specification.No : Special )

Labour Charges for old Stone fully dressing and Fixing for bothiyal uthiram charges including pointing with special grinding lime mortoar 1:1.5 and all lifting charges etc.complete complying with standard specifications and as directed by the departmental officers.(TNBP. Specification.No : Special )

Labour Charges for old Stone fully dressing and Fixing compound wall charges including pointing with special grinding lime mortoar 1:1.5 and all lifting charges etc.complete complying with standard specifications and as directed by the departmental officers.(TNBP. Specification.No : Special )

Labour Charges for New Stone Thun workfully dressing and Fixing charges including pointing with special grinding lime mortoar 1:1.5 and all lifting charges etc.complete complying with standard specifications and as directed by the departmental officers.(TNBP. Specification.No : Special )

Labour Charges for New Stone Bothiyal workfully dressing and Fixing charges including pointing with special grinding lime mortoar 1:1.5 and all lifting charges etc.complete complying with standard specifications and as directed by the departmental officers.(TNBP. Specification.No : Special )

Labour Charges for New Stone Uthiram workfully dressing and Fixing charges including pointing with special grinding lime mortoar 1:1.5 and all lifting charges etc.complete complying with standard specifications and as directed by the departmental officers.(TNBP. Specification.No : Special )

Labour Charges for new compound wall charges including pointing with special grinding lime mortoar 1:1.5 and all lifting charges etc.complete complying with standard specifications and as directed by the departmental officers.(TNBP. Specification.No : Special )

Restoration by providing herbal water wash(Combination of Venthayam powder 20%, Siyakai Powder 10%, Arapu powder 5%, Boonthi kottai powder 50%, Arugampul powder 3%, Nannari ver powder 3%, Vettiver powder 3%, Korai kizhangu powder 3%, and sembaruthi leaf powder 3% total 100%) are used for removel of lime wash on stone and oil smudge) and approrimats methodology to restore the originalities of the existing granite structure inclusive of hire charges scaffolding arrangements conveyance charges for tools & plants and machinaries to the workship spot and cleaning the site after completion of work etc complete complying with standard specification and as directed by the departmental officers.

Pointing with lime mortar 1:1.5 ( one of lime and one and half of M. sand) with special grinding lime mortar using with jaggery & galnut as directed including all labour charges, tools and plants neat finishing curing etc complete compling the standard specification.(The lime used should be sourced from Pollachi which is highly iron fortified and suitable for structural and masonry works.)(TNBP. Specification.No : 60 & special )

SUB TOTAL

GST 18 %