West Bengal Agro Industries Corporation Limited Tender

Cement Concrete Pavement (laying manually) Construction of un-reinforced, dowel jointed at expansion and construction joint only, plain cement concrete pavement, thickness as per design, over a prepared sub base, with cement content as per IRC: 15-2011, coarse and fine aggregates conforming to IS:383, maximum size of coarse aggregate not exceeding 25 mm, mixed in a batch mix plant / RMC and appropriate weigh batcher using approved mix design (as per IRC:44 2008), laid in approved fixed side formwork (steel channel, laying and fixing of 125 micron thick polythene film, wedges, steel plates including levelling the formwork as per drawing, spreading the concrete with shovels, rakes, compacted using needle, screed and plate vibrators and finished in continuous operation including provision of contraction and expansion, construction joints, applying debonding strips, primer, polysulphide sealant, dowel bars, near approaches to bridge/ culvert and construction joints, admixtures as approved, curing of concrete slabs for 14-days, using curing compound (where specified) and water finishing to lines and grade as per drawing and Technical Specification Clause 1501 for Rural Roads of MORD. (i) With Batch Mix Plant cum Note: 1. Construction Wing will add the cost & carriage of 0.9 cum/m³ crushed stone aggregates, cement, dowel bar & tie rod and cost of sand (vide Table II1 of Page 14, excl. 10% Contractor’s Profit) as per design and drawing only to arrive at consolidated rate. 2. Construction Wing will also add 3% for formwork, 5% for Overhead charges & 10% Contractor’s Profit separately over the cost of materials of Sl. 1 above. 3. The characteristic flexural strength of concrete shall not be less than 4.5 MPa. Grade- M20

Hire and labour charges for Shuttering with or without staging upto 4.0 m height using approved stout props with wooden planks/ply wood/steel sheet plate with required bracing for any kind of plain or reinforced concrete works in all sorts of minor structure including culvert, box culvert, crossdrain etc. The rate is inclusive of fitting, fixing and striking out after completion of work as per specification and direction. (b) Where staging is not required

Cost of Display Board at work site with work details mentioned.

Sub Total

GST 18%

CESS 1%