West Bengal Agro Industries Corporation Limited Tender

Ordinary Cement concrete (mix 1:1.5:3) with graded stone chips (20 mm nominal size) excluding shuttering and reinforcement if any, in ground floor as per relevant IS codes including shuttering etc as required.

Reinforcement for reinforced concrete work in all sorts of structures including distribution bars, stirrups, binders etc initial straightening and removal of loose rust (if necessary), cutting to requisite length, hooking and bending to correct shape, placing in proper position and binding with 16 gauge black annealed wire at every intersection, complete as per drawing and direction.

Hire and labour charges for shuttering with centering and necessary staging upto 4 m using approved stout props and thick hard wood planks of approved thickness with required bracing for concrete slabs, beams and columns, lintels curved or straight including fitting, fixing and striking out after completion of works (upto roof of ground floor. (f) 25 mm to 30 mm thick wooden shuttering as per decision and direction of Engineer-in-charge.

Holding down bolt with nut including 100 x 100 x 6 mm plate washer at bottom fitted complete and packing the hole with cement concrete or cement grout as directed. (i) 25 mm dia bolt (a) 750 mm long

Plaster (to wall, floor, ceiling etc.) with sand and cement mortar including rounding off or chamfering corners as directed and raking out joints including throating, nosing and drip course, scaffolding/staging where necessary (Ground floor).[Excluding cost of chipping over concrete surface]

Errection of Single ST pole of 8 mtr long over the existing RCC foundation including necessary arrangement etc as required.

Supply & Fixing carring of header/structure for fxing of 6 nos Flood Light made of 6x65mm Dia 500mm long CHS pipe and MS angle frame 40x40x6mm structure tip portion is cover with 750x750x3mm thick top plate welded with angle frame structure 4 nos angle frame each 300mm long. The header is also extra supported by 4nos vertical angle of above specification Includling providing of 6nos hole for locking/checknut device with the frame size) 300x300 mm to the top & ST pole for fixing 6nos Flood. the complete header is also strengthening with design MS flat size 500mm 6mm thick including Scoffloling arrangemetn for lifting the sarne at the top of 12mtr long ST pole as per diretion of EIC including painting.

Painting of Steel Tubular Pole of lengths and no. of coats of paint, as given below with ready mixed paint/primer of approved make, and brand incl. preparation of surface by sand paper/emery paper, cleaning etc. for receiving fresh coat of paint a) Upto 9.0 mtr. long pole i. One coat of red lead/Zinc chromate priming

ii. 1st coat of synthetic enamel paint over the primer

iii. 2nd coat of synthetic enamel paint over the 1st coat

Supply of 26W (including all losses) All In One Solar LED Street Lighting System with minimum system lumen output of 4500 lumens, 12V 6OWatt Peak- PV Module, 380 Wh Lithium Ferro Phosphate (LIFePo4) battery, Integrated MPPT charger with drive and eficiency of both Charger & driver is of 90%. The luminaire shall have a rated sýstem lifetime of 50,000 burning hours at L70 and CCT of 5700 K. It has Pressure Die Cast aluminium housing with UV stabilized Polytarbọnate front cover. The luminaire shall have CRI of 70 and Protection of lP 65. It has in-built motion sensor and LED indicator for Charging and discharging of battery. The luminaire provides 2 days battery backup with factory setting dimming profile & PIR sensor. It has Horizorntal & Vertical Pole Mounting options and Tilt angle can be adjustable in between 0- 15 degree. LM 79 report and Type Test Certificate to be submitted for luminaire, LM 80 report for LED source issued by LED manufacturer and Test reports of Solar PV module, Battery and Charge Controller. Similar to Philips Make Sunstay "BRP710 LED45 CW MR S1 12V LFP Solar IN.

Supply & Fixing Information Sign Board 500x30Omm fabricated with MS Sheet 16SWG and ISA frame 25X25x4mm Including Painting and lettering with approved paint as per Instructlon of authority.

Sub Total

GST 18%

CESS 1%