Rural Engineering Department Tender

Providing, laying, spreading and compacting stone aggregates of specific sizes 22.4-53mmto water bound macadam specification including spreading in uniform thickness, hand packing, rolling with smooth wheel roller 80-100 KN in stages to proper grade and camber, applying and brooming, crushable screening to fill up the interstices of coarse aggregate, watering and compacting to the required density grading 3 as per technical specification Clause 405.

Providing and applying primer coat with bitumen emulsion (SS-1) on prepared surface of granular base including cleaning of road surface and spraying primer at the rate of 0.70-1.0 kg/sqm using mechanical means as per Technical Specification Clause 502

Providing and applying tack coat with Bitumen emulsion (RS-1) using emulsion distributor at the rate of 0.25 to 0.30 kg per sqm on the prepared granular surfaces treated with primer & cleaned with Hydraulic broom as per Technical Specification Clause 503.(Rates are including all Taxes but excluding GST)

Providing, laying and rolling of open - graded premix carpet of 20 mm Average thickness composed of 13.2 mm to 5.6 mm aggregates using VG-10 grade Bitumen to required line, grade and level to serve as wearing course on a previously prepared base, including mixing in a suitable Plant, laying & rolling and rolling with a smooth wheeled roller 8-10 tonne capacity, finished to required level and grades.as per Technical specifications clause 508.

Providing and laying seal coat by Manual means with VG-10 grade bitumen sealing the voids in a bituminious surface laid to the specified levels grades and cross fall using Type C as per technical specification Clause 510.(Rates are including all Taxes but excluding GST)

Construction of un-reinforced, Plain cement concrete pavement, thickness as per design, over a prepared sub base, with 43 grade cement or any other type as per clause 1501.2.2 M 30 (grade) coarse and fine aggregates conforming to IS:383, maximum size of coarse aggregate not exceeding 25 mm, mixed in a concrete mixer of not less than 0.2 cum capacity and appropriate weigh batcher using approved mix design, laid in approved fixed side formwork (steel channel, laying and fixing of 125 micron thick polythene film, wedges, steel plates including levelling the formwork as per drawing), spreading the concrete with shovels , rakes, compacted using needle, screed and plate vibrators and finished in continuous operation including provision of contracton and expansion, construction joints applying debonding strips, primer, sealant, near approaches to bridge/culvert and construction joints admixtures as approved, curing of concrete slabs for 14-days, lines and grade as per drawing and Technical Specification Clause 1501(Rates are including all Taxes but excluding GST)

RCC Work in M-30 with cement , coarse sand & graded Stone Grit of approoved quary for SLAB As SI sl. No. 20 New (ii) (Rates are including all Taxes but excluding GST)

Brick edging on both side of the road of M-150 bricks 8 cm. (3") wide and 12 cm. (4.5" ) deep laid with mud mortar i/c all labour & supply of brick finished to required template & ramming the excavated earth as directed by E/I. as SI 765

M.s. or iron work for Plain Works for RCC etc i/c all its cutting , bending , placing etc but excluding Binding wire. As SI 504 (Rates are including all Taxes but excluding GST)

Excavation in foundation in ordinary soil (Loam, Clay or Sand) Including lift upto 1.50 m and lead upto 30m and including filling watering and ramming of excavated earth into the trenches or into the space between the building and the sides of foundation trenches or into the plinth and removal and disposal of surplus earth as directed by the Engineer In-charge upto a distance of 30m from the foundation trenches. as SI 251 (Rates are including all Taxes but excluding GST)

Providing and laying cement concrete in 1:6:12 (1 Cement : 6 Fine sand : 12 graded stone aggregate 40 mm nominal size) and curing complete, Including cost of form work. in Foundation. etc. Complete of work.as SI 273(Rates are including all Taxes but excluding GST)

Class-150 (Non Modular) brick work in 1:4 cement and Coarse sand mortar in foundation and plinth including supply of all materials, labour and T&P etc. required for proper completion of the work.as SI 305 (Rates are including all Taxes but excluding GST)

Supply and laying of RCC NP-3 Hume pipe including cost of all material, labour, T&P etc. complete.(Rates are including all Taxes but excluding GST) 350 mm dia

Providing and laying Cement concrete in 1:2:4 with cement, approoved Coarse sand & M-150 stone grit 20 mm nominal size and curing complete, including cost of form work in foundation and floors. As SI 279(a) (Rates are including all Taxes but excluding GST)

12mm thick Cement plaster in 1:4 (1 cement : 4 Coarse Sand) mortar at brick wall with finished even and smooth.as SI 584 (Rates are including all Taxes but excluding GST)

Reinforced cement concrete M15 grade kilometre stone/local stone of standard design as per IRC:8 fixing in position including painting and printing, etc as per drawing and Technical Specification Clause 1703 (Rates are including all Taxes but excluding GST)

Rainforced cement concrete M-15 grade 200 meter stone of standard design including painting and printing,etc (Rates are including all Taxes but excluding GST)