Water Supply And Sanitation Department Tender

REPAIR OF PUMP CHAMBER

Conglomerate floor 50mm thick cement concrete rate 1:2:4 on 100mm thick cement concrete 1:8:16 and 100mm sand filling

Providing and fixing of Glass strips 4mm thick in floors

50mm wide

40mm wide

Providing and fixing of ceiling fan of reputed make such as Crompton or equivalent

Supplying & fixing glass panes including special metal sash putty of approved make.

Centring and shuttering for flat surfaces such as suspended floors, roofs, landings, chajjas, shelves etc.

Reinforced cement concrete M-20 with cement @375/kg per cum hand mixed but excluding steel reinforcement centring and shuttering in superstructure.

Extra for machanical mixer used by the contractor at his own cost.

Extra for using vibrator used by the contractor at his own cost.

Applying Pink Primer or-aluminium priming coat including preparation of surface With special quality paint

Painting two coats excluding priming coat with ready mixed paint in all shades on new wood work With special quality paint

White washing 3 coats inside of pump chamber

Finishing wall with exterior decorative cement based paint such as snowcem robbiacem etc. on new work in two coats to give even shade. Quanity as per Sr. No. 17 Marked “C”

Preparation of plastered surfaces for distempering including surface, applying filling with approved quality filler consisting of plaster of Paris and chalk mitti including finishing the surface to the required finish complete. Inside pump Chamber. Quantity as per Sr No.17 marked (A)

Distempering with dry distemper of approved manufacture two coats over one priming coat to give an even shade. Qty as per sr No.36

PUMPING MACHINERY Providing & Installing Testing & Commissioning of one No. Electrically driven Submersible Pumping set of reputed make capable of delivering 145 LPM against a head of 46 mtr along-with electric panel board consisting of electric appliandiv.gsp such as automatic Starter, Main Switch. Volt Meter, Ampere Meter, ELCB, Shunt Capacitor, Single Phase Preventer, Indicating Lamps, MVB/MCCBs etc. including M.S. Column Pipe of suitable size 60 m (in 3 m Lengths each with flanges, screwed and welded on both sides) rubber gaskets, nuts and bolts submersible cable (of reputed make) complete in all respects. As per ISI 1239-2004

Rate of Motor with Pump

Panel Board

Submersible cable Size 2.50mm2

Column Pipe (G.I) 50 mm i/d

Providing & Installing 150 mm dia delivery main (from Tube-well to duck foot bend including cost of C.I.D/F Pipes, D/F Sluice Valves, D/F Non Return Valve & Specials as C.I. Bends, Tail Piece Tees, Pressure gauge, Air Valve,,V notch haudi etc. inside the Pump chamber as per DWSS standard design and analysis complete in all respects. (Annexure-3) As per IS1536-2001 & 1538-1993 reaffirmed 1999 and electro steel Casting/Kesoram pipe make).

Disinfection Unit: Providing Installing testing and commissioning and one no. electronically actuated, diaphragm operated, metering system, chemical dosing chlorinator, suitable for delivering 0.5 to 6 leter of bleaching powder solution/ sodium hypo solution per hrs under maximum deliver pressure upto 7kg/cm2 and suction left not less than 1.5 meter.

RCC OHSR Construction of one No. RCC OHSR 25000 Ltrs capacity having height of 18 m up to FSL and 15.50 m upto sill from formation level complete with external RCC stair case with landing slabs at each staging RCC roof, ventilator single main hole cover lightening conductor etc. complete as described in schedule No.3. Providing and fixing D.I. K-9 D/F expansion joints latest bell mouth and D/F puddle collars as per DWSS design on basis of enclosed drawing. Duck foot bends, Conforming to ISI - 13382 and C.I/D.I. D/F sluice Valve duly ISI marked (IS-14846-2000 or latest) one each with inlet, outlet and scour pipes, including providing and installing inlet, outlet scour pipe and overflow DI double flanged pressure pipes DI K-9 horizontally cast in sand moulds as per IS 8329-2000 and latest duly ISI marked from bottom dome to duck foot bend and further up to 2.75 mtr as per detail specification. TMT steel & painting of all complete shall be included in cost & P/F aluminium leader inside the OHSR complete in all respect as per specifications. (The specifications & drawing are based on safe bearing capacity of soil of is less than 8.75 tone per sqm. In case the safe bearing capacity of sail is less than 8.75 tone per Sqm. The contractor shall submit his own design for foundation portion based on actual safe bearing capacity as per DWSS specifications. The difference in quantities from the standard drawing based on 8.75 tone per sqm safe bearing capacity will be paid as per CSR+ Prevailing Ceiling Preminum including providing and fixing automatic Electronic Water Level control Device and Construction of Plinth protection around OHSR with masonry toe wall with 40 mm thick CC 1:2:4 on top over 100 mm thick CC 1:8:16 & inside earth filling, including overflow scower haudi complete in all respects.

uPVC RISING MAIN Providing, Fixing, laying, jointing, cutting & testing of uPVC Pipes & Specials (10 kg./cm2) including cost of excavation complete in all respects as per DWSS standard analysis. (Supreme /Finolex/Prince/Kissan/Moulding,Jain irrection Make or equivalent make)

160mm o/d (Mechanical)

Sluice Valve & Sluice Valve Chambers

Providing & fixing C.I D/F Sluice Valves ISI marked 14846-2000, including cost of tail piece, rubber joint, gland dori, Nuts, bolts & accessories, complete in all respects as per DWSS standard analysis

150 mm Nominal Bore (N.B.)

Construction of brick masonry sluice valve chamber size 0.90m x 0.90m as per DWSS standard Drawing & Analysis.

DEVELOPMENT OF WATER WORKS SITE. Providing & fixing 1.2mtr high fencing around the head works site with 1.65 meter post, placed every 2.5 meters apart, embedded in cement concrete blocks and every tenth post to be strutted with three rows of G.I. Barbed wire weighing 9.34 Kg per 100 meters (minimum) and fixing with GI staples tied to 6mm bar nib, with binding wire or by providing cut, including drilling holes in the post, including cost of posts, winding wire, strutted earth work in the post & aluminum painting complete in all respects as per DWSS standard Drawing and analysis. Annexure-6

Providing & Fixing precast pre-stressed cement concrete fencing pole M-40 by 4 Nos. parallel high tensile entwined wire (ISI marked wire 4mm dia fencing pole size at bottom 4"x4", size top 3" x 4", Length 6ft, hooks 6 No. including cost of excavation, sand filling and erection complete in all respects.

Providing & fixing D-Hook complete with MS Bolts size 300mm x 18mm as per DWSS standard Drawing and analysis

Construction of brick masonry corner pillar including cost of cement pointing including cost of material complete in all respects as per DWSS standard Drawing & Analysis.

Construction of masonry gate pillar including cost of MS Steel Gate size 1.22 m x 1.37 m as per DWSS standard Drawing and analysis

Construction of Foot Path with masonry toe wall & earth filling and Cement Concrete 1:8:16 with 40 mm gauge stone aggregate, 40 mm thick cement concrete topping 1:2:4, inside water works as per DWSS standard Drawing and analysis.

Providing & fixing MS sign Board as per DWSS standard design and analysis.1

Providing, Fixing, laying, jointing, cutting & testing of uPVC Pipes & Specials (6 kg./cm2) including cost of excavation complete in all respects as per DWSS standard analysis. (Supreme /Finolex/Prince/Kissan/Moulding,Jain irrection Make or equivalent make)

Excavation with JCB

uPVC Pipe 63 mm o/d

uPVC Pipe 90 mm o/d

uPVC Pipe 110 mm o/d

Excavation with Manually

uPVC Pipe 63 mm o/d

uPVC Pipe 90 mm o/d

Providing & fixing C.I D/F S.V. including cost of tail piece, rubber insertion, gland dori, Nut bolts & accessories complete in all respects. ISI marked/Kirloskar/Audco or equivalent make)

100mm i/d

80 mm i/d

Providing, fixing and jointing ISI marked Gun-Metal peet valves (Heavy Pattern) as per IS 778 with had wheels, on G.I Pipe lines laid in the ground or inside buildings including all carriage complete.

65 mm i/d Gun metal peet valve heavy pattern

Construction of masonry sluice valve chamber size 0.60m x 0.60m as per DWSS standard Drawing & Analysis.

Construction of masonry sluice valve chamber size 0.90m x 0.90m as per DWSS standard Drawing & Analysis.

Dismantling and restoration brick paving complete in all respect as per DWSS standard approved analysis.

PVC Pipe 63mm o/d

Contractor shall be quote rates only for dismantling of mettaled road & back filling with excavated earth fully compacted the restoration of the mettaled road to its original condition will be done by the concerned department i.e. PWD (B&R) PMB/Panchayati Raj)

90mm o/d 50 No road cut x 4 mtr

Dismantling and restoration of Cement Concrete Road complete in all respect as per DWSS standard approved analysis. Annexure-16

63mm o/d

90mm o/d

Dismantling and restoration of interlocking tile complete in all respect as per DWSS standard approved analysis.

63mm o/d

House water connection Water Connection Providing proposed water connection to house hold up to wall with providing, laying jointing testing G.I. pipe line 15 mm i/d = 2.50 mtr, B-class as per CSR 28.36 (A), (Above GL). Providing & fixing MDPE including cost of specials such as tees, bends, sockets, elbow, etc cutting, threading and testing in trenches in the ground and ISI 15 mm i/d GM ferrule as per IS 2692 and 3" i/d clamp with C.I. bib cock 15 mm i/d as per IS: 210 with stainless steel spindle of approved make as per CSR 30.65 (b)

Water Meter Providing and fixing multijet water meter to household including cost of specials such as tees bends, sockets, elbow, peet valve, union, nippes and hooks etc cutting, threading and testing complete in all respect.260

Environmental Management Charges

Making lawn including ploughing & dragging with 'Sohaga' breaking of clods, removal of earth rubbish dressing & supplying doob grass roots and planting at 15cm, apart including supplying and spreading of farm yeard manure @ 0.18 cum per 100 sqm & loosening

Supplying and planting permanent trees including digging of earth pits size 75cmx75cmx75cm deep refilling the excavated earth with manure supplied @ 0.113 cum each and watering supplying through tractor tanker. (Trees like Neem, Ashoka, Dake, Arjun etc.

Planting ground cover plants including digging and refilling of beds with excavated soild and FYM, Fertilizer and insecticides, planting of saplings at 30cm distance from plant to plant and row, providing and fixing brick tiles edging.

Plating, Flower beds including digging and refilling of beds with excavated soil and FYM, fertilizer and insecticides, planting of sapling at 30 cm distance from plant to plant and row to row

Provision for one way stand post with khura complete in all respects

O&M W/S System for 3 months including O&M repair of leakage, Supply of full time pump operator-cum-Chowkidar Supply of Sodium, hypochlorite solution for disinfection for 3 months after completion of work.