Cauvery Neeravari Nigam Limited Tender

PWDSR2023-24Volume-III,PageNo.9,ItemNo.2.5(ii)b - Clearing and grubbing road land including uprooting rank vegetation, grass, bushes, shrubs, saplings and trees girth up to 300 mm, removal of stumps of trees cut earlier and disposal of unserviceable materials and stacking of serviceable material to be used or auctioned, including removal and disposal of top organic soil not exceeding 150 mm in thickness..(ii) By Mechanical Means using Dozer,b) In area of thorny jungle.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-I,PageNo.38,ItemNo.1.14.1 - Earth work excavation for Foundation by mechanical means for all works & depth upto 3 m, as per drawing and technical specifications, including setting out, shoring, strutting, barricading, caution lights, including dressing of excavated surfaces, disposing off or levelling the excavated earth or sorting & stacking the selected earth for reuse in a radius of 50 m and lift upto 1.5 m including cost of labour, tools, usage of machinery & other appurtenaces required to complete the work In all kinds of soils Depth upto 3 m .., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.17,ItemNo.3.7 - Compacting original ground supporting embankment Loosening, leveling and Compacting original ground supporting embankment to facilitate placement of first layer of embankment, scarified to a depth of 150 mm, mixed with water at OMC and then compacted by rolling so as to achieve minimum dry density as given in Table 300-2 for embankment construction .., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-I,PageNo.33,ItemNo.1.7 - Construction of Embankment with approved materials deposited at site from roadway cutting and excavation from drain and foundation of other structures graded with desired compaction .., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-I,PageNo.34,ItemNo.1.8 - Construction of Embankment by excavating the available approved Gravel/Murrum deposited at a place or borrow pits during or prior excavation with all lifts and lead, transportation to site, spreading, grading to required slope and compacting to meet the requirement complete as per specifications, including cost of labour,rolling,water ,all materials ,usage& all other appurtenaces required to complete the work.

PWDSR2023-24Volume-III,PageNo.17,ItemNo.3.6 - Construction of sub-grade and earthen shoulders with approved material obtained from borrow pits with all lifts & leads, transporting to site, spreading, grading to required slope and compacted to meet requirement of table No. 300-2 .., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.23,ItemNo.4.1(A)(v) - Construction of Granular Sub-Base of required grading as per design mixing in a mechanical mix plant at OMC, carriage of mixed Material to work site, spreading in uniform layers with motor grader on prepared surface and compacting with vibratory power roller to achieve the desired density, complete as per clause 401 (v) For Grading -V Material.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.26,ItemNo.4.17 - Wet Mix Macadam (Plant mix method) Providing, laying, spreading and compacting graded stone aggregate to wet mix macadam specification including premixing the Material with water at OMC in mechanical mix plant carriage of mixed Material by tipper to site, laying in uniform layers with paver/grader in sub-base / base course on well prepared surface and compacting with vibratory roller to achieve the desired density.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.31,ItemNo.5.1A(i) - Providing and applying primer coat with SS1 grade Bitumen Emulsion on prepared surface of granular base including cleaning of road surface and spraying primer at the rate of 0.70 kg/m2 using mechanical means..,etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.31,ItemNo.5.3(i) - Providing and applying tack coat with RS1 Bituminous Emulsion using emulsion pressure distributor at the rate of 0.20 kg/m2 on the prepared bituminous surface cleaned with mechanical broom.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.33,ItemNo.5.8(ii)C - Bituminous Macadam Grading - II for traffic less than 20 MSA Providing and laying Bituminous Macadam with 40/60 TPH capacity hot mix plant using crushed aggregates of specified grading premixed with bituminous binder VG-40 @ 3.4% by weight of mix, transported to site, laid over a previously prepared surface with mechanical paver finisher to the required grade, level and alignment and rolled as per clauses 501.6 and 501.7 to achieve the desired compaction.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.43,ItemNo.5.31 - Providing and laying Semi Dense Bituminous Concrete with 40/60 TPH capacity hot mix plant batch type using crushed aggregates of specified grading premixed with bituminous binder VG-30 @ 5% by weight of mix and filler, transported to site, laid over a previously prepared surface with mechanical paver finisher to the required grade, level and alignment and rolled as per MoRTH V revision..., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.67,ItemNo.8.16(ii) - Reinforced cement concrete M15grade kilometre stone of standard design as per IRC:8-1980, fixing in position including painting and printing etc (ii) Ordinary Kilometer Stone (Precast).., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.67,ItemNo.8.18 - Boundary pillar/Guard Stone. Reinforced cement concrete M15 grade boundary pillars of standard design as per IRC:25, fixed in position including finishing and lettering but excluding painting .., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.67,ItemNo.8.16(iii) - Reinforced cement concrete M15grade kilometre stone of standard design as per IRC:8-1980, fixing in position including painting and printing etc (iii) 200 m stone (precast)

PWDSR2023-24Volume-III,PageNo.71,ItemNo.8.31 - Rumble Strips Provision of 15 nos rumble strips covered with premix bituminous carpet, 15-20 mm high at center, 250 mm wide placed at 1 m center to center at approved locations to control speed, marked with white strips of road marking paint .., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.65,ItemNo.8.7 - Direction and Place Identification Signs upto 0.9 m2 Size Board Providing and erecting direction and place identification retro-reflectorised sign as per IRC:67:2012 made of high intensity grade sheeting vide clause 801.3, fixed over aluminium sheeting, 2 mm thick or Aluminium composite material sheet with overall thickness of 4mm with area not exceeding 0.9 m2 fixed over back support frame of min 35 x 35 x 3mm angle mounted on a mild steel circular pipe 65 NB, firmly fixed to the ground by means of properly designed foundation with M25 grade cement concrete 45 x 45 x 60 cm, 60 cm below ground level as per approved drawing.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.63,64,ItemNo.8.5(iv) - A.Retro-Reflectorised Traffic Signs Providing and fixing of retro- reflectorised cautionary, mandatory and informatory sign as per IRC:67:2012 made of Class B Type IV retro reflective sheeting fixed over 2 mm thick aluminium sheeting vide clause 803.1, 3mm/4mm thick Aluminium composite material sheet depending on the size of the sign fixed over the back support frame of min 25 x 25 x 3mm angle mounted on a mild steel circular pipe 65 NB, 3.2 mm thickness firmly fixed to the ground by means of properly designed foundation with M25 grade cement concrete 45 cm x 45 cm x 60 cm, 60 cm below ground level as per approved drawing.The sign shall be maintained as per section 12 of IRC:67:2012.( iv ) 60 cm equilateral triangle.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.149,ItemNo16.28 - Providing and constructing un-reinforced plain cement concrete pavement, thickness as per design, over a prepared sub base, with 43 grade cement or any other type as per Clause 1501.2.2 M30 (Grade), coarse and fine aggregates conforming to IS:383:2016:, maximum size of coarse aggregate not exceeding 25 mm, mixed in a concrete mixer of not less than 0.2 cum capacity and appropriate weigh batcher using approved mix design, laid in approved fixed side formwork (steel channel, laying and fixing of 125 micron thick polythene film, wedges, steel plates including levelling the formwork as per drawing), spreading the concrete with shovels, rakes, compacted using needle, screed and plate vibrators and finished in continuous operation including construction joints, primer, sealant, curing of concrete slabs for 14-days, and water finishing to lines and grade as per drawing and technical specification clause 1501 with all lead, lifts, loading & unloading charges, cost and conveyance of all materials, labour, equipments etc., complete. as per the directions of the Engineer-in-charge of the work.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.10,ItemNo.2.8(ii)a - Dismantling of existing structures like culverts, bridges, retaining walls and other structure comprising of masonry, cement concrete, wood work, steel work, including T&P and scaffolding wherever necessary, sorting the dismantled material, disposal of unserviceable material and stacking the serviceable material with all lifts and lead. A Cement Concrete Grade M-15 & M-20.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.11,ItemNo.2.17(B) - Removing all type of Hume Pipes and Stacking including Earthwork and Dismantling of Masonry Works..B) Above 600 mm to 900 mm dia.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-I,PageNo.15,ItemNo.2.1.3 - Providing and laying in position plain cement concrete for levelling course for all works in foundation. The granite/trap/basalt crushed graded coarse aggregates and fine aggregates as per relevant IS Codes machine mixed, laid in layers not exceeding 150 mm thickness, well compacted using plate vibrators, including all lead & lifts, cost of all materials of quality, labour, Usage charges of machineries, curing, and all the other appurtenances required to complete the work as per technical specifications. (The cost of steel reinforcement & formwork shall be paid separately)Mix 1:3:6 (M10) Using 40 mm nominal size graded crushed coarse aggregates etc., complete with all lead and lifts as directed by EIC of Work.

PWDSR2023-24Volume-I,PageNo.15,ItemNo.2.1.3 - Addition for formwork, centring and scaffolding ((M10 concrete) including all lead & lifts, cost of all materials of quality, labour, Usage charges of machineries, curing, and all the other appurtenances required to complete the work as per technical specifications.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-I,PageNo.16,ItemNo.2.4.1 - Providing and laying in position Reinforced cement concrete for all Sub structures of building, Irrigation works, Sub structure works of bridges, Drain works & other parallel works from 0.50m to 3.50 m height. The granite/trap/basalt crushed graded coarse aggregates and fine aggregates as per relevant IS Codes machine mixed with super plasticisers, laid in layers, well compacted using needle vibrators, providing weep holes wherever necesary, including all lead & lifts, cost of all materials of quality, confirming to the requirements of relevant IS codes, labour, Usage charges of machinery, curing and all other appurtenances required to complete the work as per technical specifications. (The cost of steel reinforcement & formwork to be paid separately) Mix 1:2:4 (M15) Using 20 mm nominal size graded crushed coarse aggregates.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-I,PageNo.16,ItemNo.2.4.1 - Addition for formwork, centring and scaffolding ((M15) Using 20 mm nominal size) including all lead & lifts, cost of all materials of quality, labour, Usage charges of machineries, curing, and all the other appurtenances required to complete the work as per technical specifications.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-I,PageNo.16,ItemNo.2.5.2 - Providing and laying in position Reinforced cement concrete for all Super structures of building , Road works, Water works, Irrigation works & super structure works of bridges upto 3.50 m height. The granite/ trap/basalt crushed graded coarse aggregates and fine aggregates as per relevant IS Codes machine mixed with super plasticisers laid in layers, well compacted using needle vibrators. The cost includes all lead & lifts, cost of all materials, quality confirming to the requirements of relevant IS codes , labour, Usage charges of machinery, curing and all other appurtenances required to complete the work as per technical specifications. (The cost of steel reinforcement, dowel bars & formwork to be paid separately)M25 Design Mix Using 20 mm nominal size graded crushed coarse aggregates.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-I,PageNo.16,ItemNo.2.5.2 - Addition for formwork, centring and scaffolding ((M25) Using 20 mm nominal size) including all lead & lifts, cost of all materials of quality, labour, Usage charges of machineries, curing, and all the other appurtenances required to complete the work as per technical specifications.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24,Volume-IPageNo:18,ItemNo:2.11(h) - Supplying, fitting and placing TMT FE 550 / 550D Steel Reinforcement including cost of all materials, machinery, labour, cleaning, straightening, cutting, bending, hooking, laping/welding joints, tying with binding wire / soft annealed steel wire and other ancilary operations complete as per drawing and technical specification(h)All other type of structures.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.129,ItemNo.14.4(A) - Providing and laying Pitching on slopes laid over prepared filter media including boulder apron laid dry in front of toe of embankment complete as per drawing and Technical specifications.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.117,ItemNo.12.3(A) - Back filling behind abutment, wing wall and return wall complete including compaction as per drawing and Technical Specification A Granular material.., etc Complete with all lead and lifts as directed by EIC of work.

PWDSR2023-24Volume-III,PageNo.117,ItemNo.12.2 - Providing weep holes in Brick masonry/Plain/ Reinforced concrete abutment, wing wall/ return wall with PVC Pipe 110mm outer dia at 2 kg per m2, extending through the full width of the structure with slope of 1V :20H towards drawing foce. Complete as per drawing and Technical Specifications