Konkan Railway Corporation Limited Tender
Download documents of Goa KRCL Tender
Costs
EMD
₹ 2,88,800Document Cost
Refer DocumentsTender Fee
Refer Documents
Description
Scription for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user
Contact
Tender Id
KR-KW-EL-AMC-T-35-2024-KARWAR-DIVISION-ELECTRICAL/KRCLTender No
KR-KW-EL-AMC-T-35-2024Tender Authority
Konkan Railway Corporation Limited ViewPurchaser Address
-Website
http://ireps.gov.in
GEM & Bid Advisory Services
Get portal registration, tender bidding, product/service listing or vendor/MSME certification services at a nominal cost
BOQ Items
... More
CURRENT TRANSFORMER 600/5 AMPS INSULATION LEVEL 0.813 AS PER IS 2705 / 1992 OF MAKE YOKINS OR ANY RDSO APPROVED MAKE.
-
-
1
... More
Din type HRC fuse link 125 Amps breaking Capacity 25 KA at 1000V AC of M/s Ferraz make (1051 CP GLB 20.127 125 - X095700J) or SIBA (Type NH00M,NH1L,gb, part No: 2038903.125) or EFFN or ETI make confirming to IS 13703/IEC-269-2 suitable for use of LHB variant EOG coaches.
25
1425
35625
... More
Removal of defective battery cells and fitting of new cells
1
301
301
... More
Repairing of refrigerator &Deep Freezer - Replacement of compressor. 24
1
7650
7650.3
... More
Single phase Emergency Battery Charger (EBC) for EOG Type LHB coaches as per RCF 24 specification No. EDTS 163 Rev. C, corrigendum-4 or latest. Rated capacity 2.5KW current rating-20 Amp input voltage-230volts AC . Out put voltage 110 volts DC Make-ICF/MCF/RCF/RDSO approved only.
4
21500
86000
... More
Set of various meters used in LHB power car. A set contains 03 nos of voltmeter, 01 nos of Multifunction energy meter, 01 nos of ammeter i.e. 3 items & 5 in nos. as per as per RCF 28 specification no. EDTS 103, REV-D, AM-7 or latest. Material make is L&T/ AE/ SOCCOMEC / RISHABH/ SIEMENS / SCHNEIDER/ YOKINS or MULLER only. Quantity- 02 set (03 items & 10 in nos). Details are as follows 1) Ammeter NP72, class 1.5, CT 400/5A, scale 0%u2026.400/800A. As per RCF specification EDTS 103, Rev-D, Amd-7, make should be of L&T/ AE/ SOCCOMEC /RISHABH/ SIEMENS / SCHNEIDER/ YOKINS or MULLER. One power car contains 02 nos of ammeter. 2) Multifunction energy meter 5A or 1A CT input for LV or HV networks AC or DC Aux. Supply measurement & display UVI In PQSPFFEa, Er, & Es THD for V&I with lead bar graph in 96*96 sq. mm. flush mounted case with six direct access key & backlit LCD, accuracy class 1.0 as per RCF specification EDTS 103, Rev-D, Amd-7 or latest. Material make should be of M/s. AE part No. DIRIS A40 or equivalent part no. of L&T/ SOCCOMEC / RISHABH/ SIEMENS / SCHNEIDER/ YOKINS or MULLER only. One power car contains 02 nos of multifunction energy meter. 3) Voltmeter NW72 net1, 0-800V, 800 VAC as per RCF specification EDTS 103, Rev-D, Amd-7 or latest. Material make should be o f L&T part no. NW72( Net-1) 0-800V, 800V AC or equivalent part no. of AE/ SOCCOMEC / RISHABH/ SIEMENS / SCHNEIDER/ YOKINS or MULLER only. One power car contains 0MAKE6 nos of this kind of voltmeter. Accepted offer AE
4
13379
53516
... More
Digital frequency meter with LED display, size-96 sq.mm. for measuring frequency, 26 suitable for voltage- 50-550V AC, 50 HZ, CL 0.2, True RMS, Aux. supply-(12-48 V DC), 4 digit, 3 line, 7 segment display, Make- YOKINS, model-Y-9-3HZ. or similar in specification. as per RDSO/SPEC/PE/TL/0195-2019(REV.0). Make- AE/Muller+Zeigier/Rishbabh/L&T/YOKINS or similar
2
1369
2738.18
... More
Disconnecting and Earthing device, 8 pole, 2 Way with ON-OFF, ON LOAD,125 AMPS 4 750 V (1000 V insulation) 2 No+ 2NC with heavy duty handle and pad locking arrangement in earth position mounted in a stainless steel enclosure suitable for AC 230 Duty Confirming to IS: 13947/IEC 947 as per L&T (Salzer) Cat No.73342SLB32LOGBBS or M/S SCHALTBAU cat No.M137-0827407 for LHB AC coaches.
4
45840
183362.36
... More
DC to DC converter for switch gear cabinet of LHB AC coaches -110/24 V, 240W,10A confirming to RDSO SPEC.NO.RDSO/PE/SPEC/AC/0184-2015[REV O] MAKE:-ABB PART NO.CP-C-24/10 OR EQUIVALENT OF COSEL / POWERTECH / ASTEC / PHOENIX.
6
5853
35118
... More
Digital Voltmeter with LED display size 96 sq. mm, 0-800 V AC, CL1, True RMS, Aux. 14 supply- (12-48 V DC), 4 digit, 3 line, 7 segment display. Make- YOKINS, model no.-Y-9-3V3 or similar specification as per RDSO/SPEC/PE/TL/0195-2019(REV.0). MAKE- AE/Muller+Zeigier/Rishabh/L&T/YOKINS or similar in specification.
2
1574
3148
... More
Removing or fitting of mono block battery sets including terminal connection etc.
1
1472
1472.7
... More
Disconnecting and Earthing device, 8 pole, 2 way, No-OFF, on load 63 Amps, 750 V AC 5 (1000V Insulation), 4 NO auxiliary contact, with heavy handle and pad locking arrangement in earth position without sheet steel/Stainless Steel enclosure for AC- 23 duty conforming to IS-13947/ IEC 947 as per RCF spec. EDTS355(Rev-1),similar to Salzer (L&T) make cat no.63A S63-73342-B03- LOGBS/Kaycee make cat.no.63808920A2 /4V490X. (TL COACHES).
10
15900
159000
... More
LED INDICATORS 110 VOLTS DC RED YELLOW, WHITE AND GREEN. 9
12
141
1698.12
... More
Repairing of 9/15 KVA step down transformer for LHB TL coaches including spares.
10
9347
93475
... More
Power Contactor 750 Amps, 1000V, 3 pole AC- 3 duty with coil voltage 250-500V, 50/60 42 HZ/DC (Code- 71) and Auxiliary contacts (1 NO+ 1 NC) suitable for switch board cabinet of LHB AC power car, confirming to RCF Spec. No. EDTS 103-Rev-d, Am-7. Make: ABB, Part No. AF750-30-11, Order Code: 1SFL637001R7111. as per Specn. RCF SPEC NO. EDTS 103-REV-D, AM-7.
6
67080
402480
... More
LT HRC FUSE 25 AMPS MODEL NO: NH 000 gG OF SIEMENS MAKE OR ANY SIMILAR RDSO APPROVED MAKE.
12
234
2819.52
... More
Replacement of socket, switch assembly for laptop/mobile charging points.
1
496
496.79
... More
Removing or fixing of axle pulley for axle under frame. 3
1
1675
1675.7
... More
Repairing of refrigerator &Deep Freezer - Shifting, fixing & connecting of refrigerator OR deep freezer 32
1
1530
1530.52
... More
Repair/ Reconditioning of 4.5 KW alternator, regulator board by carrying out the following works - Replacement of potentiometer for voltage and current control.
-
-
12
... More
Measuring Monitoring Relay (LT MMR), Voltage phase control 400/480 VAC +/- 15%, 50-60 Hz, control 300-500 V AC, Conf. to RDSO Spec no. RDSO/PE/SPEC/AC/0184 -2015 (Rev.1), Suitable for switch board cabinet of LHB type EOG AC Coaches.
10
1088
10880
... More
Analog DC Ammeter NP-72 for battery 50A-0-50A, size 72 X 72mm as per serial No.129 of Bill of material of RDSO. Spec. No. RDSO/PE/SPEC/AC/0184-2015(REV.0) suitable for use in Switch Board Cabinet of LHB type AC coaches. Accepted Makes : Yokins / Zeigler / Rishabh / L&T.
6
350
2100
... More
Repair/ Reconditioning of 4.5 KW alternator, regulator board by carrying out the following works - Renewal of complete internal wiring
1
301
301
... More
SHUNT 0-50 AMPS 0.75 mV. FOR MEASUREMENT OF BATTERY VOLTAGE AND CHARGING VOLTAGE.
6
3176
19058.46
... More
RC Filters for HOG power supply system in LHB EOG AC and Non AC coaches as per RDSO modification sheet No. RDSO/PE/MS/AC/0051-2011, Rev-2, amendment 1. Brands: Bhasin Packard/NACEI/AEL/RAMYAA/TROLEX/ ABROL/NEC/ISG/TRINITRON
4
1450
5800
... More
High voltage HRC Fuse base/holder suitable for din type HRC fuse used in LHB AC 37 coaches, with current rating 125 Amps, voltage rating 1000 Volts, braking capacity 80 KA, size NH1L, Category GB, suitable for fitment with existing fuse of dimension similar to SIBA Catalogue no. 2028003.125, place of installation SIF50 to SIF55 of switch board cabinet of LHB AC coaches. Acceptable makes : SIBA, EFEN, Ferraz, ETI, Eaton Bussmann
10
750
7500
... More
Ammeter NP-72, 0 to 100A: 200A, Cl.1.5 for current transformer 100/1A, size 72x72 19 mm analog type, as per serial no. 12 item no. P01 of bill of material of RDSO spec. no.- RDSO/PE/SPEC/AC/0184-2015(REV.0) suitable for use in switch board cabinet of LHB TYPE AC COACHES. MAKE - YOKINS
6
255
1530
... More
Repairing of refrigerator &Deep Freezer - Replacement of over load relay 25
1
727
727
... More
Removing or fixing of 4.5 KW alternator from/on bogie under frame. 2
1
1222
1222.52
... More
Repairing of refrigerator &Deep Freezer - Replacement of capillary tubes 29
1
757
757.58
... More
MONOBLOCK PUMP 0.5 HP 3 PHASE 415 VOLTS, WITH TOP FOR LHB AC COACHES.
6
4878
29273.88
... More
AC MCBs SINGLE POLE 06 AMPS TO 10 AMPS 30
10
378
3782.5
... More
Repair/ Reconditioning of 4.5 KW alternator, regulator board by carrying out the following works - Replacement of auxiliary diodes and field diodes with resistance.
1
971
971.2
... More
Providing man power ( semi skilled ) to assist departmental staff for maintenance of RA coach, transportation of heavy materials from store to depot, house keeping depot office etc.(Unil shall be read as Per person per day)
3500
3307500
3307500
... More
LED Type Flashing Tail Lamp for LHB Type Power Car with Flashing Unit System and 7 VHF Charging Socket as per RCF Drg. No. LP-75001 and LP-73200, Alt No.-C and conforming to RCF Specification No. EDTS-215 (Rev.-Nil) with Amendment 1. [ICF ID-2300060 / RCF ID-2400017 / MCF ID- 2700026] (Rev.-Nil) with Amendment 1. EATON BUSSMANN
10
13278
132780
... More
Repair/ Reconditioning of 4.5 KW alternator, regulator board by carrying out the 16 following works - Other minor repairs including replacement of terminal lugs, terminal blocks and painting in inner and outer surface with one coat of red oxide primer and 2 coats of yellow enamelled paint.
1
385
385.9
... More
LT HRC FUSE 100 AMPS MODEL NO: NH 000 gG OF SIEMENS MAKE OR ANY SIMILAR RDSO APPROVED MAKE. 21
12
485
5831.28
... More
Set of three RC(resistance capacitance) filter,Each RC filter consist of 01 OHM, 10 watt resistance connected in series with parallel connected 1.5 MFD, 850/1000V range capacitor 32 (epcos/vishay or equivalant),in each ARM of Star connected to be provided between phase & earth of 60KVA transformer as per Drawing no- RDSO/PE/SK/AC/0155-2015 rev-0 or latest of Siemens,medha,ramyaa or Similar with mounting arrangement as per Sheet no-2 of RDSO drawing no -RDSO/PE/SK/AC/0188-2015 rev-0 or latest Accepted Make/Brand-SURE or Similar Offered make- INTEG. Firm to submit GC and TC of product alongwith supply.
4
1388
5552
... More
Fitment of set of V belts for transom mounted 4.5 KW Alternator 4
1
200
200.7
... More
Power Contactor 100 Amps, 415 Volt, 4 Pole, Duty AC-1, Operating Coil Voltage 48-130 9 Volt AC/DC, 50/60 HZ/DC with Auxiliary Contact Block (Front Mounting) 2 NO.+ 2NC. and surge suppressor diode. Make ABB,Model No. AF50-40-00-Coil Code 70 with Auxiliary Contact Block CA5-22E or equivalent make of Schneider / Siemens or latest Railway approved make suitable for Switch Board cabinet of Non AC LHB Coaches.
20
7200
144000
... More
Overhauling & repairing of 4.5 KW brush less alternator consisting of the following activities - Replacement of driving end bearing witk SKFNU-311 C3 and non driving end bearing with SFK 6309
1
2946
2946.6
... More
WATER RAISING PUMP CONTROLLER FOR LHB AC COACHES.KIND MAKE OR ANY RDSO APPROVED SIMILAR MAKE.
6
3555
21333.3
... More
AMMETER SELECTOR SWITCH
6
355
2130.66
... More
VOLTAGE SELECTOR SWITCH 16
6
355
2130.66
... More
ROTARY SWITCH 4 POLE 4 WAY 06 AMPS 415 VOLTS OF SALZER MAKE OR ANY RDSO APPROVED MAKE. 5
6
751
4506.96
... More
AC MCBs 3 POLE 10 AMPS TO 32 AMPS 28
10
1149
11498.8
... More
Measuring & Monitoring Relay (MMR) 750 volt AC 15%, 50-60 Hz with features of on 1 delay measuring phase to phase, neutral, over voltage, under voltage, asymmetry and phase sequence to relay- code no.DPCOID 750. Accepted make- ABB, L&T, AEG, Siemens, Schneider, Carlo Gavazi.
100
5598
559800
... More
HOG A&B Main power contactors 3 Pole 1000 V AC, 50 Hz, Suitable for 500 KVA 750 V AC on load switching under AC 6A category at temperature of 70 Degree C and coil voltage of 415 v + 44 10 % - 20% AC with surge suppressor 2 NO + 2NC as per RDSO Spec No: RDSO/PE/SPEC/D/TL/0195- 2019 (Rev-0) Suitable for switch board cabinet for HOG Complaint LSLRD Coaches make (As per RDSO Spec bill of material)- ABB Model No; AF1250-30-11, L&T Model No: MVO 820, SIEMENS Model No; 3TF69448 CQ 7Z A 02,
4
119778
479112
... More
Set of LSLRD HOG Panel LED indicating lamps with i). diameter 22.5, 24 VDC, Colour Green 100 Nos, White 100 Nos, Red 100 Nos, Amber 100 Nos, corresponding to RDSO specification No: RDSO/PE/SPEC/D/TL/0195 2019 (Rev-0) or latest. Approved Makes/ Model SIEMENS 3SB52856 (HE 46 01, HG 01, HC01, HL01, L&T (EPLG024C, EPLW024C, EPLR024C, EPLA024C) or equivalent in ESBEE/ TEKNIK/ SCHNEIDER only accepted. ii). diameter 22.5, 110 VDC, Colour Green 50 Nos, White 50 Nos, Red 50 Nos, Amber 50 Nos, corresponding to RDSO specification No: RDSO/PE/SPEC/D/TL/0195 2019 (Rev-0) or latest. Approved Makes/ Model SIEMENS 3SB52856 (HE 04, HG 04, HC04, HL04, or equivalent in L&T, ESBEE/ TEKNIK/ SCHNEIDER only accepted.
1
43000
43000
... More
Spare coil suitable for ABB make Model No: AF1250-30-11 Feeders 1 &2 and bus coupler, Power contactors, 3 pole, 1000 V AC, 50 Hz suitable for 500 KVA 750 V AC on load switching 47 under AC 6A category at temperature of 70 Degree C and coil voltage of 110 v + / - 25% -30% DC with surge suppressor 2 NO + 2NC as per RDSO Spec No: RDSO/PE/SPEC/D/TL/0195-2019 (Rev-0) Suitable for switch board cabinet for HOG Complaint LSLRD Coaches. Material should be supplied along with OEM proof of purchase, test certificate, make ABB, Product ID 1SFN156170R6906
4
41459
165839
... More
AC MCBs 2 POLE 06 AMPS TO 16 AMPS 29
10
885
8855.5
... More
Supply and fitting V belt set of C122 4 belts in matched group for alternator. 40
1
2939
2939.5
... More
Repair /Rewinding of 110 V,DC carriage fan by carrying out the following - Replacement of both bearings by new bearings.
1
301
301
... More
Solid state relay for control safety loop, DC3-32 V confirming to RCF specification no. EDTS 103 Rev-D, Am-7. Material is RD0605-D of M/s Carlo Gavazi (as per EDTS 103 BOM).
2
11500
23000
... More
Repair/ Reconditioning of 4.5 KW alternator, regulator board by carrying out the following works - Replacement of magnetic amplifier with mouldings
1
3132
3132
... More
Repair /Rewinding of 110 V,DC carriage fan by carrying out the following - Repairs/renewal of carbon brushes and brush holders complete. 22
1
134
134.52
... More
Feeder 1,2 and Bus coupler power contactors S2 K1, S2 K2, S2K3, 3 Pole 1000 V AC 50 45 Hz Suitable for 500 KVA 750 V AC on load switching under AC 6A category at temperature of 70 Degree C and coil voltage of 110 v + / - 25% -30% DC with surge suppressor 2 NO + 2NC as per RDSO Spec No: RDSO/PE/SPEC/D/TL/0195-2019 (Rev-1) or latest Suitable for switch board cabinet for HOG Complaint LSLRD Coaches make ABB, L&T , SIEMENS , SCHNEIDER only.
4
119500
478000
... More
NET SELECTOR SWITCH 6
6
292
1756.86
... More
DC MCBs DOUBLE POLE UP TO 400 VOLTS 06 AMPS TO 16 AMPS
12
1244
14930.64
... More
Repairing of refrigerator &Deep Freezer - Replacement of power cable 1.5 sq mm,3 core
1
49
49.55
... More
ELCB FOR HOT WATER BOILER AND DEEP FREEZER. 25 AMPS, 30 mA , SIEMENS OR SIMILAR MAKE. 14
12
3285
39430.56
... More
LED INDICATORS 24 VOLTS DC RED YELLOW ,WHITE AND GREEN. 10
12
141
1698.12
... More
Repairing of 60 KV step down transformer including spares. 2
10
49486
494866
... More
Regulated Battery Charger for LHB coaches conforming to RDSO specification no. 3 RDSO /PE/SPEC/AC/0129-2009 (REV.1) & as per ICF specification No.EDTS 074 REV-C, CORR-1 .SPECN: RDSO SPECIFICATION NO. RDSO /PE/SPEC/AC 0129-2009 REV.1 or latest. Make Autometers Alliance Ltd., Noida.
6
137000
822000
... More
CAPACITOR BANK FOR LHB EOG/HOG TYPE POWER CAR as per Spec.No. EDML130, REV-1, COR- 6 , TYPE-2, Packing Instruction - PI042 VER1.0
5
15999
79995
... More
LT HRC FUSE 80 AMPS MODEL NO: NH 000 gG OF SIEMENS MAKE OR ANY SIMILAR RDSO APPROVED MAKE.
12
532
6386.64
... More
PUSH SWITCH (DPB/5 (AIRON) suitable for MB & Company make Emergency Battery Charger (EBC), suited to LHB (EOG) type AC coaches as per RCFs Specification No. EDTS-163, Rev-C, Corrigendum-3 or latest. Make: MB & Company / Bhasin Packard / Electrowaves / Stesalit.
10
130
1300
... More
CONTACTOR 4 POLE WITH 415 VOLT COIL, 125 AMPS, WITH ADD ON BLOCK 2NO + 2 NC OF MODEL CA5-22E OF ABB MAKE OR SIMILAR MAKES OF SCHNEIDER, SIEMENS, AND L &T
6
13743
82460.28
... More
HRC fuse, Tubular type, 2 Amp, 1.2 KV AC suitable for use in Power Panel (HT side) of 6 LHB variant EOG Coaches as per drawing no. PCEE/GS/2 AMP FUSE/02 and confirming to RDSO Specification no. RDSO/PE/SPEC/AC/0184-2015 (Rev. 0) or latest and RDSO Modification letter no. EL/7.1.108/SBC dtd. 16.10.2018. Accepted make: Similar to category no. 184000.2 of SIBA / HVW-IR (2 Amp) of BUSSMANN (ETN).
200
195
39000
... More
Overhauling & repairing of 4.5 KW brush less alternator consisting of the following 7 activities - Replacement of alternator shaft and alternator pully complete with all fixing accessories viz nuts, washers, key etc. The shaft shall be machined out of EN 3 grade material and shall be tested for cracks ultrasonically.
1
3434
3434
... More
LT HRC FUSE 40 AMPS MODEL NO: NH 000 gG OF SIEMENS MAKE OR ANY SIMILAR RDSO APPROVED MAKE.
12
437
5254.56
... More
Repair /Rewinding of 110 V,DC carriage fan by carrying out the following - Rewinding and providing field coil assembly as per standard practice.
1
585
585.3
... More
Analog voltmeter 0-1000 V, NW72 square panel mounting type, AC insulation class CI- 43 1, accuracy: 1.5%, size 72mmx72mm with 750V marking, suitable for fixing in LHB AC coaches switch board cabinet as per RDSO spec. : RDSO/PE/SPEC/AC/0184-2015, Rev.1, RDSO approved makes: AE/Rishabh/Muller+Zieghfer/ L&T/Yokins.
12
359
4308
... More
Repair/ Reconditioning of 4.5 KW alternator, regulator board by carrying out the following works - Replacement of CT along with burden resistance
1
1272
1272.1
... More
Set of various rotary switches used in switch board cabinet (SBC) of LHB AC coaches. one set consist of 01 Nos Ammeter selection rotary switch, 01 Nos voltmeter selection rotary switch, 01 Nos Feeder selection rotary switch and 01 Nos power supply on/off switch i.e. 4 items and 4 Nos. Material is as per RDSO Specification No.RDSO/PE/SPEC/0184-2015( Rev-1). Details are as follows: 1)Ammeter selection rotary switch with marking " L1-L2-L3 ". Rotary switch is M/s. Siemens part no. 3ST1400-2RQ08 of M/s.L&T or M/s. Salzer.One SBC contain 01 Nos of Ammeter selection rotary switch. 16 2) Voltmeter selector switch with marking L1-L2, L2-L3, L3-L-1 rated voltage 1000 VAC. Material is M/s.Siemens part no. 3ST1400-1RK08 or M/s.L&T or Ms.Salzer. One SBC contains 2 Nos.of Voltmeter selection rotary switch. 3) Feeder selection rotary switch with marking "I-O-II" net1-local main supply net2 (Change over switch with O-position 3 pole rated voltage 690V AC, rated current 16A. Rotary switch is M/s.Siemens part no. 3SB50002DB01 + 3SB5400-OA or M/s. L&T.One SBC contain 1 nos of feeder selection rotary switch. 4) Toggle Switch 0-1 power supply on/off switch with socket and 2 NO is M/s.Siemens part no. 3SB50002AB01 + 3SB5400-OE or M/s. L&T or M/s.Salzer. One SBC contains 01Nos of power supply On/Off switch. Accepted makes : L&T, Siemens,GE.
2
900
1800
... More
Analog Voltmeter 0-1000 V, NW72 square panel mounting type, AC insulation class CI- 22 1, accuracy: 1.5%, size 72mmx72mm with 750V marking, suitable for fixing in LHB AC coaches switch board cabinet as per RDSO spec. : RDSO/PE/SPEC/AC/0184-2015, Rev.1, RDSO approved makes: AE / Rishabh / Muller + Zieghfer / L&T / Yokins.
6
338
2031
... More
Supply of spare parts to be supplied during AMC as and when required by KRCL. Spares / materials are to be procured from OEMs / RDSO Approved Vendors / manufacturer or 1 authorized dealers. Firm has to submit a copy of Tax invoice / purchase bill during supply of material. Payment shall be made as per Tax invoice plus 10% handling charges. Quantity & unit : No estimate can be given of the quantity or value of spares which may be ordered. However, withdrawal orders shall be placed on actual requirement basis from time to time during currency of contract.
1
1500000
1500000
... More
Repair/ Reconditioning of 4.5 KW alternator, regulator board by carrying out the following works - Rewinding of field transformer with moulding
1
971
971.2
... More
Removal of defective alternator. 35
1
1960
1960.05
... More
MPCB 1.0- 1.6 AMPS FOR PUMPS IN LHB AC COACHES. MODEL MS 116 OF ABB MAKE OR SIMILAR RDSO APPROVED MAKE.
6
2108
12650.46
... More
Fitting of new alternator. 36
1
1960
1960.05
... More
Fitting of new regulator. 38
1
100
100.3
... More
Power Contactor 12 Amps, 415 V, 50 HZ, 4 Pole, AC-3 duty, operating coil voltage 110 40 Volt DC (77-137 V DC), with Surge Suppressor Diode 77V-150DC, and Auxiliary Contact Block (Front Mounting) 2 NO + 2NC. Make ABB, Model No. TAL-16-40-00 with Auxiliary Contact Block CA5-22E & Surge Suppressor RT5/150 or SCHNEIDER Make Cat No-LCID125FD or SIEMENS Make Cat No-3RT1317- 1BF40, Suitable for Switch Gear Cabinet of LHB AC Coaches.
6
1875
11250
... More
Metering Transformer capacity 300 VA, 750V/415V/110V AC, 3 phase TYPE-RG-36/82/7- 13 TP suitable for LHB power cars. material is of M/S. BHASIN PACKARD PART NO. RG-36-82-7 TP OR M/S.VIMAL/PANTRONICS/HACEL/RAMAYA Electro Gear transformer as per RDSO specification no.EDTS- 103, REV. D, AM-7.
4
8380
33520
... More
Voltage measuring Transformer/metering Transformer: 750/415V, 3 phase, 50Hz, AC, Capacity: 300 VA, suitable for metering purpose in LHB type EOG power cars. Type: RG-36-82-7-TP. Make: Bhasin Packard, Vimal,Pantronics, NACEI, Ramya Electro gear.
4
7555
30220
... More
Contactor 3 Pole, 16 Amp capacity suitable for 415V, 50 HZ AC, coil voltage 110 DC with surge suppressor ( coil voltage range 77-137 v dc) with inc auxiliery contact block similar to ABB CODE TAL-16-30-01, RT 5/150 generally conforming to IS- 13947 PT.- 4/1993.]
6
1194
7166.1
... More
Din Rail Mounted Earth Leakage Relay (Residual Current Monitor Relay) With Operating 23 Voltage 12-48 V AC/DC, Confirming To IEC 62020-1, Suitable For SBC 2 Of LHB Power car. Type / Make RCM470ly-21 of Bender or Elr-3c Of Fanox Or Rd3m-48 Of Abb As Per RCF Specification EDTS-103 Rev-D AM-4 .
6
7000
42000
... More
ELECTRICAL CHIMNEY FOR HOT BUFFET CARS IN LHB COACHES. 230 VOLTS 0.19 KW, 22
3
14223
42671.94
... More
Repairing of refrigerator &Deep Freezer - Replacement of thermo- stats
1
597
597.09
... More
Multifunction energy meter with LCD display in 96x96 Sq.mm flush mount, 27 measurement, i.e., VI, HZ, P, PF, max, Avg, H, e, etc., 4 lines display suitable for DG set power panel of LHB power car. Make: Socomec, Model No.DIRIS A40. or Rishab make, Model No.LM 1360 or equivalent.
2
4150
8300
... More
72 X 72 mm Front Panel voltmeter range 0-150 DC Volts, flush type with rubber gasket accuracy class 1.5 as per IS :248 (P-2)-2003, NW-72, suitable for LHB AC coaches. Accepted makes : AE / MULLER / ZEIGLER / RISHABH/YOKINS/L&T.
6
449
2694
... More
Earth fault Relay 110V DC (Voltage Type) EFRA-II. Pick Up Voltage 50 Volt DC, Aux. 29 Voltage 110 Volt DC. ENGLISH ELECTRIC/ALSTOM Type: VAG Model NO.: SPECM 2YF328M (VAG11/VAA11) OR IT'S EXACT EQUIVALENT. M/S GEC type VAG Model No. SPEC M2YF 328M Spec: M/S GEC type VAG Model No. SPECM2YF328M.
2
8000
16000
... More
Overhauling & repairing of 4.5 KW brush less alternator consisting of the following 8 activities - Other minor works, viz, replacement of cast nylon bushes, cleaning and painting of alternator with 2 coats of yellow enameled paint after applying 2 coats of metallic primer greasing and oiling etc.
1
687
687
... More
200 AMPS 4 POLE POWER CONTACTOR FOR 750 VOLT AC AS WELL AS 415 VOLT AC APPLICATION HAVING CONTROL COIL OF 415 VOLT AC WITH ADDITIONAL SIDE MOUNTING 2 POLE AUXILIARY CONTACT, SUITABLE FOR LHB COACHES SIMILAR to MAKE: ABB, TYPE CODE:EK110-40-11- AR (FOR MAIN CONTACT WITH CONTROL COIL), CAL16-11A (FOR AUX. CONTACT). Accepted Make/BRAND:SCHNEIDER ICF/MCF/RCF approved sources only
-
-
38
... More
CONTACTOR 4 POLE WITH 110 VOLT DC COIL, 6 AMPS, OF MODEL TKC 6- 312 WITH SNUBBER CIRCUIT OF ABB MAKE OR SIMILAR MAKES OF SCHNEIDER, SIEMENS, AND L &T (PUMP CONTACTOR). 26
6
873
5243.88
... More
ROTARY SWITCH 4 POLE 4 WAY 16 AMPS 415 VOLTS OF SALZER MAKE OR ANY RDSO APPROVED MAKE.
6
1428
8570.7
... More
Fixing & connecting of mobile charging inverter. 34
1
229
229
... More
Repair /Rewinding of 110 V,DC carriage fan by carrying out the following - Rewinding and providing armature coil assembly as per standard practice.
1
887
887.5
... More
ANALOG TYPE VOLTMETER 72X 72 mm 0-150 VOLTS DC 15
6
912
5473.5
... More
Removal of defective regulator. 37
1
100
100.3
... More
Ammeter Selector Switch Knob-B Engine (SBC 2 Cabinet ) as per Salzer model no:16A- S16-61325- TDYR . Make: Salzer (L&T) or Kaycee for LHB Power Cars.
6
250
1500
... More
Inter vehicular coupler Unit ( 500 Amp. rating ) for EOG LHB type AC coaches / Power car conforming to RDSO Specification No. RDSO / PE / SPEC / AC / 0177 (Rev.0) - 2013.
4
221400
885600
... More
Repairing of refrigerator &Deep Freezer - Replacement of capacitor
1
581
581
... More
Double inlet Centrifugal Blower assembly complete with mounting brackets suitable for 8 exhaust fan in LHB type coaches, type - double inlet centrifugal blower speed: 1500 RPM, Air Volume: 625 CMH, power input: 200 W, current: 0.4 Amps, Voltage: 415 V 3 phase AC, Frequency: 50 Hz, conforming to RCF specification No. EDTS 331,Amendment-1, type -1, Corr.1,2 & 3. Accepted brand: INTEG. SEM or similar.
30
5498
164940
... More
Repairing of refrigerator &Deep Freezer - Attending gas leakage, including supply of gas & gas charging. 27
1
3672
3672.3
... More
Overhauling & repairing of 4.5 KW brush less alternator consisting of the following 5 activities - Rewinding of 3 phase winding and winding with suitable size copper winding wire as per ISS and accepted practice complete with replacement of terminal plate made out of 12mm thick fabric based bakelite sheet. The coil shall be formed and vacuum impregnated after varnishing and nomex paper shall be added between coil insulation.
1
9795
9795.6
... More
Supply and fitting V belt set of C122 12 belts in matched group for alternator. 39
1
8817
8817.31
... More
200VA CONTROL TRANSFORMER 750/415V, TYPE-II, , 50Hz, SINGLE PHASE' "H'' CLASS INSULATION, DRY TYPE & AIR COOLED, ALONG WITH FUSES COMPLETE, SUITABLE FOR SWITCH BOARD 35 CABINET OF EOG LHB TYPE AC COACHES CONFIRMING TO RDSO SPECIFICATION No. RDSO/PE/SPEC/AC/0203-2020 (Rev-0). ACCEPTED MAKE AS PER RDSO LETTER NO. EL/7.1.108/SBC/MAIN FILE, DATED 16,04,202I ARE AS UNDER :- BHASIN PACKARD, NACEI , TROLEX, RAMYAA, TRINITRON, KONTACT CONSORTIUM, ABROL, ASK POWERTEC OR ANY RDSO APPROVED MAKE
20
7500
150000
... More
415 volt,50Hz, 3 pole,9 AMPS,AC 3 duty,operating coil voltage 110 volt DC(77- 41 137),power contactor, with surge suppressor diode 77V-150DC,and auxilary contact block(front mounting)1 no.+1 NC of M/s ABB Make TAL-16-30-01 auxiliary contactt block CA5-01 and CA5-10, surge suppressor RTS/150,or SCHNEIDER -LC 1 D9 FD or SIEMENS 3RT 1016-1JF 42 with auxiliaries,surge suppressor suitable for switchgear rake of LHB AC coaches.
6
1075
6450
... More
SMOKE DETECTOR UNIT AGNI MAKE OR SIMILAR RDSO APPROVED MAKE.
6
7338
44028.3
... More
A set of spares of M/S BHASIN PACKARD make emergency battery charger, single 25 phase, 50hz, for EOG type LHB AC coaches as per RCF specification no. EDTS-163 rev ' C ' corrigendum - 4 or latest, Material to be procured from OEM only, are as follows:- 1) PCB control card : EBC-310-1A qty. = 01 no/set 2) Display meter, suitable for emergency battery charger EDTS-163 qty. = 04 nos/set (one set consists of 02 items and qty 05 nos)
6
11105
66634.8
... More
Repair/ Reconditioning of 4.5 KW alternator, regulator board by carrying out the following works - Replacement of main diodes along with heat shrinks if damaged.
1
787
787.1
... More
Supply of high voltage fuse link rating - 25 amps ,volt- 1000,VAC, breaking capacity - 120KA for use in LHB non AC-coaches as per RDSO spec no. EDTS 355 rev -.1 or latest . Makes: Siba, Eaton / Bussman / Efeen / Ferraz / ETI / Siemens / Schneider / L&T.
50
1150
57500
... More
LED INDICATORS 230 VOLTS AC RED YELLOW, BLUE AND GREEN. 8
12
141
1698.12
... More
ROTARY SWITCH 4 POLE 4 WAY 32 AMPS 415 VOLTS OF SALZER MAKE OR ANY RDSO APPROVED MAKE.
6
1600
9601.32
... More
Repairing of refrigerator &Deep Freezer - Replacement of blower motor 28
1
2264
2264.5
... More
Repair /Rewinding of 110 V,DC carriage fan by carrying out the following - Repairs/Renewal of commutator assembly
1
2930
2930.1
... More
AC MCBs 4 POLE 16 AMPS TO 63 AMPS 27
10
1663
16634.1
Evaluation Notes How It Works ?
Potential Partner
Select Your Requirements