Military Engineer Services Tender
... More
To inquire about any e-tender the Andaman & Nicobar Islands government has posted, Bidassist gives a one-stop solution i.e. being a registered bidder one can find every eprocurement Punjab tender on BidAssist. BidAassist has collated each and every Eproc Andaman & Nicobar Island Tender on its website. Looking for Andaman & Nicobar Island tenders online or going through the cumbersome government websites for it, has been made easier with the help of BidAssist.
Military Engineer Services - MES Tender
Electrical Generators And Transformers
Electrical and Electronics
Eprocure
Opening Date13 May 2025
Closing Date3 Jun 2025
Tender Amount₹ 44,90,000
Costs
EMD
₹ 89,800Document Cost
₹ 500Tender Fee
Refer Documents
Description
Scription for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user this is tender description for unregistered user
Contact
Tender Id
2025_MES_707779_1Tender No
8569/E8Tender Authority
Military Engineer Services ViewPurchaser Address
-Website
http://http://mes.gov.in/
GEM & Bid Advisory Services
Get portal registration, tender bidding, product/service listing or vendor/MSME certification services at a nominal cost
Documents
BOQ Items
... More
250 KVA & 200 KVA DG Sets of Make Cummins 02 Nos installed at INHS Dhanvantari
6
10
60
... More
Supply only following spares suitable for cummins 750 KVA Engine Model No KTA 2300 G for carrying out repairs under Item No.1 above for :-
-
-
-
... More
Water separator/coolant filter bearing Cat Part No WF2075 or equivalent (4 Nos for each engine)
12
10
120
... More
Air filter bearing Cat Part No 8200015 or equivalent (2 Nos for each engine)
3
10
30
... More
Fuel filter bearing cat part No FF5511 or equivalent (2 Nos for each engine)
6
10
60
... More
Fuel filter bearing cat part No LF516 or equivalent (4 Nos for each engine)
12
10
120
... More
Lube oil filter LF16029 or equivalent (2 Nos for each engine)
6
10
60
... More
Supply only following spares suitable for cummins 650 KVA Engine Model No QSK19G7 for carrying out repairs under Item No.1 above for :-
-
-
-
... More
Water separator filter bearing Cat Part No WF2076 or equivalent (1 Nos for each engine)
3
10
30
... More
Air filter bearing Cat Part No 8200016132191508/ 4020551 or equivalent ( 1 Nos for each engine)
2
10
20
... More
Air filter bearing Cat Part No 8200015132192240/4020552 or equivalent ( 1 Nos for each engine)
2
10
20
... More
Fuel filter bearing cat part No FF5782 or equivalent (2 Nos for each engine)
6
10
60
... More
Fuel filter bearing cat part No FS19663 or equivalent (2 Nos for each engine)
6
10
60
... More
Fuel filter bearing cat part No FS19763 or equivalent (1 Nos for each engine)
3
10
30
... More
Lube oil filter LF14000N or equivalent (2 Nos for each engine)
6
10
60
... More
Supply only following spares suitable for cummins 200 KVA Engine Model No 6CTAA-8.3-G1 for carrying out repairs under Item No.1 above for :-
-
-
-
... More
Water separator filter bearing Cat Part No WF2152 or equivalent (1 Nos for each engine)
3
10
30
... More
Water separator filter bearing Cat Part No 3815424 or equivalent (1 Nos for each engine)
3
10
30
... More
Air filter bearing Cat Part No AF25938 or equivalent ( 1 Nos for each engine)
1
10
10
... More
Air filter bearing Cat Part No AF 25947 or equivalent ( 1 Nos for each engine)
1
10
10
... More
Fuel filter bearing cat part No FS19634 or equivalent (1 Nos for each engine)
3
10
30
... More
Lube oil filter LF9009 or equivalent (1 Nos for each engine)
3
10
30
... More
Supply only following spares suitable for cummins 250 KVA Engine Model No QSB6.7G23 for carrying out repairs under Item No.1 above for :-
-
-
-
... More
Water separator filter bearing Cat Part No WS5029422 or equivalent (1 Nos for each engine)
3
10
30
... More
Air filter bearing Cat Part No 8200796 or equivalent ( 1 Nos for each engine)
1
10
10
... More
Air filter bearing Cat Part No 8200797or equivalent ( 1 Nos for each engine)
1
10
10
... More
Fuel filter bearing cat part No 5031739 or equivalent (1 Nos for each engine)
3
10
30
... More
Lube oil filter 5031315 or equivalent (1 Nos for each engine)
3
10
30
... More
S&F in repair water pump assembly in 750/650KVA DG set of Make Cummins complete all as specified and as directed.
1
10
10
... More
Supply, topping up and filling of coolant concentrate for radiator of DG Set of any capacity and make compete all as specified and as directed.
200
10
2000
... More
Supply and filling distilled water for batteries of DG set complete all as specified and as directed.
90
10
900
... More
M&L for dismantling self starter from engine, carryingout repairs to the self starter, replacement of carbon brushes, service kit, brush holder asssembly, terminals, varnishing of 750/ 650 KVA DG set complete all as specified and as directed.
1
10
10
... More
M&L for dismantling self starter from engine, carryingout repairs to the self starter, replacement of carbon brushes, service kit, brush holder asssembly, terminals, varnishing complete for DG set capacity 250/200 KVAcomplete all as specified and as directed.
1
10
10
... More
M&L for dismantling the battery charge alternator from engine, carryingout repairs by replacement of carbon brushes, rectifier kit, diodes, varnishing the coils, replacing bearing, regulator, fixing back in the engine and connecting electrical system complete of 750 KVA/650 KVA DG set complete all as specified and as directed.
1
10
10
... More
M&L for dismantling the battery charge alternator from engine, carryingout repairs by replacement of carbon brushes, rectifier kit, diodes, varnishing the coils, replacing bearing, regulator, fixing back in the engine and connecting electrical system complete for DG set capacity upto 250/200 KVA complete all as specified and as directed.
1
10
10
... More
M&L for repair, calibration, testing and commissioning of PT fuel pump of 750/650 KVA DG set including the replacement of all service kits complete all as specified and as directed.
2
10
20
... More
M&L for repair, calibration, testing and commissioning of PT fuel pump for DG set capacity upto 250/200 KVA including the replacement of all service kits complete all as specified and as directed.
1
10
10
... More
M&L for dismantling, transporting, repair and reconditioning of water pump assembly of 750/650 KVA DG set, by replacing water pump shaft, impeller, water seal and seat, oil seal, bearings, O ring, gaskets,etc, fixing back to the engine, testing and commissioning including the replacement of all service kits complete all as specified and directed.
1
10
10
... More
M&L for dismantling, transporting, repair and reconditioning of water pump assembly DG set capacity 200/250 KVA, by replacing water pump shaft, impeller, water seal and seat, oil seal, bearings, O ring, gaskets,etc, fixing back to the engine, testing and commissioning including the replacement of all service kits complete all as specified and directed.
1
10
10
... More
S&F in repair AVR suitable for 750/650 KVA DG set complete all as specified and as directed.
1
10
10
... More
S&F in repair AVR suitable for 250/200 KVA DG set complete all as specified and as directed.
1
10
10
... More
M&L for Painting of diesel storage tank externally of capacity 15000 ltrs with one coat of synthetic enamel paint of approved quality and colour by spray painting after preparation of old paint surface including stickering tank details etc., complete all as specified and directed.
1
10
10
... More
M& L for dismantling of three phase 5 HP motor from the coil cooler of 750 KVA DG sets, transporting to workshop, opening of unserviceable winding complete, rewinding the motor with new suitable gauge super enamelled copper wire with necessary insulation materials, heating and varnishing, reassembling the motor, replacement of u/s bearings, assembling and fixing back into the coil cooler and testing complete all as specified and as directed
1
10
10
... More
S&F as in repair the lead acid battery 12 V DC 180 AH including the initial charge, terminals connector complete all as specified and as directed.
4
10
40
... More
S&F in repair fuel hose for supply/return fuel of Cummins DG Set 650/750 KVA complete all as specified and as directed.
2
10
20
... More
S&F in repair fuel hose set for supply/return fuel of Cummins/Kirloskar DG Set 250/200 KVA complete all as specified and as directed.
2
10
20
... More
S&F in repair lub oil hose set of Cummins DG Set 750/650 KVA complete all as specified and as directed.
2
10
20
... More
S&F in repair lub oil hose set of Cummins/Kirloskar DG Set of capacity 250/200 KVA complete all as specified and as directed.
2
10
20
... More
S&F in repair coolant hose set of Cummins DG Set 750/650 KVA complete all as specified and as directed.
2
10
20
... More
S&F in repair coolant hose set of Cummins/Kirloskar DG Set of capacity 250/200 KVA complete all as specified and as directed
2
10
20
... More
S&F in repairs Lub oil pressure transducer for Cummins DG Set 750/650 KVA complete all as specified and as directed.
2
10
20
... More
S&F in repairs Magnetic pick up for Cummins DG Set 750/650 KVA complete all as specified and as directed.
1
10
10
... More
S&F in repairs Low lub oil pressure safety switch for Cummins DG Set 750/650 KVA complete all as specified and as directed.
1
10
10
... More
S&F in repairs High water temperature trip safety switch of Cummins DG Set 750/650 KVA complete all as specified and as directed.
1
10
10
... More
S&F in repair Flat multi Rib belt of Cummins DG Set 750 KVA MAP DG set / 650 KVA complete all as specified and as directed.
2
10
20
... More
S&F in repair fan belts of Kirloskar/Cummins DG Set 250/200 KVA complete all as specified and as directed.
2
10
20
... More
S&F in repair shutdown valve of Cummins DG Set 750/650 KVA complete all as specified and as directed.
1
10
10
... More
S&F in repairs dynamo belt of Cummins DG Set 750/650 KVA complete all as specified and as directed.
2
10
20
... More
M&L in repair and rewinding the excitor rotor assembly of DG Set 750/650 KVA by taking out complete burnt coils, cleaning and rewinding the same by supper enamel copper wire existing guage , insulalting the coils with nomex paper, milinex sheet, heating and varnshing by varnish materials and applying one coat of bectol anti rust protection, fixing back in to the alternator, connecting the cables, starting and testing complete all as specified and as directed.
1
10
10
... More
M&L in repair AUX 105 controller for 750 KVA Cummins DG Set complete all as specified and as directed.
1
10
10
... More
M&L in repair mother board suitable for PCC 3300/ PCC 1302/ KG 745 controller for 750/650 KVA Cummins DG Set complete all as specified and as directed. Note: Software calibration if required will be measured and paid separately.
1
10
10
... More
M&L for calibration of microprocessor based PCC 3300/PCC 1302/ KG 745 controller with OEM software including reloading corrupted software , setting parameters etc for functionality of DG set complete all as dierected starting and testing the DG set on load complete all as specified and as directed.
Note: Quoted rate inclusive of software, PC/laptop and other T&P for carrying out job complete
1
10
10
... More
M&L for servicing of air circuit breaker rating 1250-1600 Amps, dismantling from the DG set panel by taking out the defective moving contact unit with fingers and its connected accessories, dismantling and servicing the defective moving contact with fingers, under voltage trip, shunt release trip, assembling and fixing back in to the panel and locking properly and testing on load complete all as specified and as directed.
2
10
20
... More
M&L for dismantling the engine turbo charger assly by taking out aircleaners, after cooler housing and its connected accessories in 750/650 KVA DG set complete dismantling and servcing by replacing the defective wheel and shaft, compressor wheel and repair kit, assembling the turbo charger and fixing back in to the engine and mouting, starting and testing the DG set on load complete all as specified and as directed.
Note. The spare required for repairs shall be measured and paid seperately. Each turbo charger will be measured as one job.
2
10
20
... More
Supply only repair kit turbo charger complete all as specified and as directed.
2
10
20
... More
Supply only gasket mounting complete all as specified and as directed.
2
10
20
... More
Supply only screw hexegonal Head cap complete all as specified and as directed.
2
10
20
... More
Supply only nut lock complete all as specified and as directed.
2
10
20
... More
M&L for taking down unserviceable solenoid switch from starter motor of 750/650 KVA DG Set, opening and removing bunrt defective parts, replacing by new solenoid switch and connecting with contacts and testing complete all as specified and as directed.
1
10
10
... More
M&L for taking down unserviceable solenoid switch from starter motor of 200 KVA DG Set, opening and removing bunrt defective parts, replacing by new solenoid switch and connecting with contacts and testing complete all as specified and as directed.
1
10
10
... More
M&L for replacement of battery lead 1.25 Mtr long consisting of multistranded copper conductor PVC insulated single core cable of 75 Sqmm size connected with 1 No battery terminal clamp at one end and copper lug at other end complete all as specified and as directed.
1
10
10
... More
S&F in repairs electronic Governor controller of Cummins DG Set 750/650 KVA complete all as specified and as directed.
1
10
10
... More
S&F in repair rotating rectifier kit diode set of Cummins DG Set 750/650 KVA complete all as specified and as directed.
1
10
10
... More
S&F in repair rotating rectifier kit diode set of kirloskar DG Set 200/250 KVA complete all as specified and as directed.
1
10
10
... More
S&F in repairs battery charger automatic type 220 V AC input and 24/12 V 10 Amps output with auto cut off, floating, indicating meters, lamps, connectig to the exisitng circuit and testing complete all as specified and as directed.
1
10
10
... More
Supply only engine oil for topping up in engine oil sump with suitable grade oil SAE-20W-40 complete all as specified and as directed.
840
10
8400
... More
Supply only engine oil for topping up in engine oil sump with suitable grade oil SAE-15W-40 complete all as specified and as directed.
630
10
6300
... More
S&F in repair under voltage relay 415 V AC suitable for LT ACB breaker 1250 Amps EDU with revers power protection conecting and testing complete all as specified and as directed.
2
10
20
... More
S&F in repairs actuator assembly of Cummins DG Set 750/650 KVA including gasket and O rings, starting and testing the DG set on load complete all as specified and as directed.
1
10
10
... More
S&F in repairs of low coolant water level sensor suitable for Cummins DG Set 750/650 KVA complete all as specified and as directed.
1
10
10
... More
S&F in repairs radiator out let pipe along with hose and clamp sets of Cummins DG Set 750/650 KVA by taking out corroded pipes from radiator assly, fixing new pipes, hose and clampset, starting and testing complete all as specified and as directed.
1
10
10
... More
M&L for fuel leakage rectification in 750/650 KVA DG set by complete dismantling of engine turbo charger connections, intake manifolds in both banks, removing STC fuel manifold along engine injectior fuel rail manifiolds along with connected hoses and accessories, replacement of set of fuel manifold O rings, STC O rings, fixing back all removed parts of manifolds and its connected items, carrying out valve and injector settings, starting and testing complete all as specified and as directed.
Note : Each turbo charger with manifold will be measured as one job.
2
10
20
... More
Supply and fix in repair Human Machine interface suitable for PCC 3300/ PCC 1302/ KG 745 controller comprising of intuitive operator interface panel that allows for complete genset control as well as
system metering, fault annunciation, configuration and diagnostics. The interface shall ihave following features:-
(a) LED indicating lamps:- genset running, remote start, not in auto, shutdown, warning, auto, manual and stop, Circuit breaker open, Circuit breaker closed.
(b) 320 x 240 pixels graphic LED backlight LCD
(c) Four tactile feel membrane switches for LCD defined operation. (d) Seven tactile feel membrane switches dedicated screen navigation buttons for up, down, left, right, ok, home and cancel
(e) Six tactile feel membrane switches dedicated to control for auto, stop, manual, manual start, fault reset and lamp test/panel lamps
(f) Two tactile feel membrane switches dedicated to control of circuit breaker
(g) Communications shall include PC tool interface with RS-485 communication port to allow the HMI to communicate with a personal computer running InPower and the HMI to communicate with the main control board
Make: Cummins Power Command HMI 320 or equivalent.
1
10
10
... More
M&L for cleaning the radiator assembly of 750 KVA DG Set of any model with the help of chemical and water through high pressure water pump at site complete including testing complete all as specified and as directed Note: Radicool wash as recommended by manufacturer as required shall be measured and paid seperately.
2
10
20
... More
M&L for cleaning the radiator assembly of 650 KVA DG Set of any model with the help of chemical and water through high pressure water pump at site complete including testing complete all as specified and as directed Note: Radicool wash as recommended by manufacturer as required shall be measured and paid seperately.
1
10
10
... More
M&L for cleaning the radiator assembly of 200 KVA DG Set of any model with the help of chemical and water through high pressure water pump at site complete including testing complete all as specified and as directed Note: Radicool wash as recommended by manufacturer as required shall be measured and paid seperately.
1
10
10
... More
Supply and filling of Radicool wash for radiator cleaning of DG Set of any capacity and make compete all as specified and as directed.
50
10
500
... More
S&F in repair fuel temperature sensor for Cummins DG Set 650 KVA complete all as specified and as directed.
1
10
10
... More
S&F in repair engine intake air temperature sensor for Cummins DG Set 750/650 KVA complete all as specified and as directed.
1
10
10
... More
S&F in repair fuel pressure monitoring sensor for Cummins DG Set 750/650 KVA complete all as specified and as directed
1
10
10
... More
Supply only cotton waste of good quality complete all as specified and as directed.
50
10
500
... More
M&L for injector and valve settings by adjusting the clearances according to engine firing orders, cleaning the prefilter cap, checking and adjusting the belts, checking and adjusting the mounting pads including replacement of unserviceable valve door gasket complete all as specified and as directed for DG set of capacity 750/650 KVA.
1
10
10
... More
M/L for diesel exhaust fluid compatible with all SCR systems suitable for CPCB IV+ diesel engines. Make: Kirloskar/TATA/Cummins/CG or equivalent
2820
10
28200
... More
M/L for draining out engine oil from lube oil sump of diesel engine of capacity 650/750 KVA, dismantling the defective lube oil sump by strip opening of nut bolts, gaskets, inspecting of leakages/cracks in lube oil sump, cleaning the lube oil sump, brazing or welding suitable for alluminium alloy sump by proper groove cutting and metal filling complete, air pressure testing after welding, refixing the same with new gasket cover, fixing nut bolts etc complete including testing DG on load all as dierected.
Note: Engine oil/ filters required will be measured and paid separately under relevant sch items
1
10
10
... More
M/L for strip opening of acoustic panels carefully keeping it in safe custody, strip opening of raditor fan belts, tension spring, radiator fan grid, radiator fan assly, disconnecting radiator pipes with connecting hose assly for taking out defective radiator assembly, dismanlting HT/LT raditor core for repairs and refixing of radiator assembly, refixing radiator fan belts, adjsuting tension spring, refixing acoustic panel complete including tesing and commissioning complete for DG set of capacity 650/750 KVA.
Note : Repair/replacement of defective radiator cores will be measured and paid separately. Quoted rate inclusive all necessary T&P for carrying out the above job.
1
10
10
... More
Supply and fixing in repair HT radiator cores made up of copper fins with lead coated brass tubes complete including pressure testing for leakages complete for DG set of capacity 650/750 KVA
1
10
10
... More
Supply and fixing in repair LT radiator cores made up of copper fins with lead coated brass tubes complete including pressure testing for leakages complete for DG set of capacity 650/750 KVA
1
10
10
... More
M/L for cleaning out HSD fuel tank of capacity above 600 Ltrs upto 1000 Ltrs by disconnecting inlet pipe connections, flushing out sediments/deposits with high pressure air, arresting leakages if any, refixing the pipes including replacement of defective inlet valves and painting the tank with two coats of synthetec enamel paint over a coat of red oxide after preparation of surfaces complete all as directed.
1
10
10
... More
M/L for cleaning out HSD fuel tank of capacity above 2000 Ltrs upto 3000 Ltrs by disconnecting inlet pipe connections, flushing out sediments/deposits with high pressure air, arresting leakages if any, refixing the pipes including replacement of defective inlet valves and painting the tank with two coats of synthetec enamel paint over a coat of red oxide after preparation of surfaces complete all as directed.
1
10
10
Evaluation Notes How It Works ?
Potential Partner
Select Your Requirements
Past BiddersThis list is curated from the bidders of the similar tenders in the past
- Bidder NameThis Information is for unsubscribed user This Information is for unsubscribed user
- Awarded Ratexx%
- Bidder NameThis Information is for unsubscribed user This Information is for unsubscribed user
- Awarded Ratexx%
- Bidder NameThis Information is for unsubscribed user This Information is for unsubscribed user
- Awarded Ratexx%