Rural Drinking Water And Sanitation Department Tender

010 - Supply, installing,testing and commissioning COMMON control panel consisting of the following INCOMING:1 No set of Phase indicating lamps with SFU of suitable rating 1 No, Analog Ammeter, 1 No Analog Voltmeter 1ni with Phase selector switch, Isolating switch OUTGOING for Main Electrical Pump: 1 No. MCB 1 No. DOL of S/D Starter suitable for respective HP 1 No. Electrcal Protection Like single Phase preventor, under voltage over Volage, under current over current & dry run protection suitable for the pump described above 1 no Indoor type NOTE: 1) DOL- Direct Online Starter 2) S-D- Star Delta Starter etc. complete. 6 to 15 HP pumps (CSR 2023-24, VOL-5, Chapter-13, P.No. 155, I.No.13.23.3)

018 - Providing and fixing suitable for 1.1 KV class UG cable filled with necessary bitumen/insulating compound complete with terminals, clamps,bolts,nuts and washers etc. with necessary materials and labour tools and equipments as per instructions of engineer incharge of work. 3x6 Sqm

009 - Supply and delivery at site of brand new best make non-return valve as per IS 778/1984 with ISI Mark and as per its latest amendments (CSR 2023-24, VOL-5, Chapter-13, P.No. 154, I.No.13.25)

003 - Providing and installation of Class SN8 Double Wall Corrugated HDPE Specials outer wall corrugated and inner wall smooth piping system in accordance with IS 16098 part 2 and conveying to work site and lowering into trenches, laying true to line and level and perfect linking at joints with the help of two "O" rings and a coupler of suitable size, including loading and unloading at both destination and cutting of pipes where ever necessary including jointing with all labour, all lead and lift including encasing the Specials around to a depth of not less than 15 cm with screened soft soil available from the excavated soil. The testing commissioning including necessary hydraulic test to the required pressure as per ISS shall be done the contractor shall have to make his own arrangement for procuring water for testing etc.complete. 75 MM ELECTRO FUSION ELBOW

022 - Providing and constructing laterite size stone masonry including cosrt of and conveyance of lall material curing etc complete as per specification IS 3620/1979 having compressive strength not less than 3.5 for saturarted dry samples

026 - Providing 15mm Cement plaster on the rough side of single or half brick wall of mis1:4 including roundign off corners wherever required smooth rending providin and removing scaffoliding including cost of material labour curing complerte as per speicification and as per directions of Engineer in Charge

011 - Supply and delivery at site 50mm(2”) dia heavy duty unplasticized PVC Column pipes with heavy duty collars,rubber profile ring,vibration control profile ring,freezing and turbulence free leak proof EPDM ring with ISI mark with its latest amendments (CSR 2023-24, VOL-5, Chapter-13, P.No. 155, I.No.13.28)

012 - Supply and delivery at site Accessories for Single Phase pumpset like SS Groove Nipples,SS Studs & Nuts,Screw Clips &water proof Insulation Tape etc complete with ISI mark (CSR 2023-24, VOL-5, Chapter-13, P.No. 155, I.No.13.30)

007 - Supply and delivery at site Brand new best make PVC insulated cable of Flat 3 core (sheathed) of nominal cross sectional area as per IS 694-1990 with ISI Mark and as per its latest amendments. 1x3x6 Sqm. (CSR 2023-24, VOL-5, Chapter13, P.No. 151, I.No.13.22)

002 - Providing and installation of Class SN8 Double Wall Corrugated HDPE Specials outer wall corrugated and inner wall smooth piping system in accordance with IS 16098 part 2 and conveying to work site and lowering into trenches, laying true to line and level and perfect linking at joints with the help of two "O" rings and a coupler of suitable size, including loading and unloading at both destination and cutting of pipes where ever necessary including jointing with all labour, all lead and lift including encasing the Specials around to a depth of not less than 15 cm with screened soft soil available from the excavated soil. The testing commissioning including necessary hydraulic test to the required pressure as per ISS shall be done the contractor shall have to make his own arrangement for procuring water for testing etc.complete. 75 MM ELECTRO FUSION COUPLER

006 - Providing Submersible Pump Set of 150mm dia suitable for bore well and confirming to IS 8034-2000;3Phase, SS Bowl & Impeller with Low volt Motor as per specifications, to work site as per necessary ammendments and instructions of engineer incharge of work. For 3 HP etc. complete 5.00 HP - 90 LPM @ 110 m = 15 STG Outlet Dia - 2.00" (CSR 2023-24, VOL-5, Chapter13, P.No. 152, I.No.13.15.7)

004 - Providing and installation of Class SN8 Double Wall Corrugated HDPE Specials outer wall corrugated and inner wall smooth piping system in accordance with IS 16098 part 2 and conveying to work site and lowering into trenches, laying true to line and level and perfect linking at joints with the help of two "O" rings and a coupler of suitable size, including loading and unloading at both destination and cutting of pipes where ever necessary including jointing with all labour, all lead and lift including encasing the Specials around to a depth of not less than 15 cm with screened soft soil available from the excavated soil. The testing commissioning including necessary hydraulic test to the required pressure as per ISS shall be done the contractor shall have to make his own arrangement for procuring water for testing etc.complete. 75 MM ELECTRO FUSION ELBOW

027 - Distempring with oil bound wahsble distemper of approved brand manufacture to give an even shade New work over and including thinnable priming coar with cement primer after throrouhly brooming the furface to remove all dirt dust mortat drops and foeign matter inclduing preparing the surface even sand paper smoonth coasrt of material labour compelete as per speicication

016 - Labour charges for erection of indoor type panel board and meter board units with all necessary materials and labour tools and equipments including cement concrete for foundation/bed etc,complete as per specification, with testing of as per instructions of engineer incharge of work. (CSR 2023-24, VOL-5, Chapter-13, P.No. 156, I.No. 13.32)

015 - Labour charges for Erection, Electrification and commissioning of Pump sets, including aligning and balancing of all items including supply and erection of two pair of supporting clamps, bore well caps, cable clips and water tight gland cable protectors, bolts, nuts, valve and gauges,tools and equipments etc., involved in the job as per specifications, with necessary tests as per specifications, with testing of as per instructions of engineer incharge of work. (CSR 2021-22, VOL-5, Chapter-13, P.No. 156, I.No. 13.32)

025 - Erection and positioning of RCC Hume pipe pump house/Cistern on size stone masory platform including transportation charges and handling,finishing with all necessary tools ,plants and materials etc.,complete as directed by the Engineer in charge of the work

001 - Earth work excavation for pipeline trenches in all kinds of soils by mechanical means as per drawing and technical specifications, including setting out, construction of shoring, strutting, barricading, caution lights, bracing, using sight rails & bonding rods at every 100 mm wherever necessary as directed, removal of stumps and other deleterious matter, dressing of sides and levelling the bottom of trench to the extent required , utilising the available excavated earth locally for the work etc., and all other appurtenances complete in the following strata.

021 - Providing and laying in position cement concrete for levelling course for all works in foundatrion The granite trap basalt crushed graded coarse agrremeets and fine aggreegates as per relvenet IS Codes Machine misxed lain in layes not exceccidng 150mm thickness weel compacted suign plate vibrators including all lead and liffs

008 - Supply and delivery at site of brand new best make gate valve as per IS 778/1984 with ISI Mark and as per its latest amendments Size 65 mm (CSR 2023-24, VOL-5, Chapter-13, P.No. 154, I.No.13.24.2)

014 - Providing main connection from pole PVC insulated sheathed steel wire cable in new trench as per IS 1554/ 1988 with latest amendments with ISI mark from KPTCL pole to meter board unit. (CSR 2021-22, VOL-5, Chapter-13, P.No. 156, I.No. 13.36)

023 - Providing and laying in position cement concrete for levelling course for all works in foundatrion The granite trap basalt crushed graded coarse agrremeets and fine aggreegates as per relvenet IS Codes Machine misxed lain in layes not exceccidng 150mm thickness weel compacted suign plate vibrators including all lead and liffs

013 - Supply and delivery at site Stringing of heavy duty Naylone/PP rope with ISI etc complete suitable for Single phase Pumpsets. (CSR 2023-24, VOL-5, Chapter-13, P.No. 155, I.No.13.31)

017 - Labour charges for providing connection using insulated sheathed steel wire cable as per IS 1554/ 1988 with latest amendments from KPTCL pole to meter board unit, with all necessary materials tools and equipments,as per specificationswith testing of as per instructions of engineer incharge of work 3x 6mm

020 - Earth work excavation for pipelines/cables by Manual means upto 600 mm trench width, as per drawing and technical specifications, including setting out, shoring, strutting, barricading, caution lights, removal of stumps and other deleterious matter, including dressing of excavated surfaces, disposing off or leveling the excavated earth or sorting & stacking the selected earth for reuse in a radius of 50 m. Filling available excavated earth (excluding rock) in trenches, plinth, sides of foundations etc. in layers not exceeding 20cm in depth, consolidating each deposited layer by ramming and watering and lift upto 1.5 m including cost of labour, tools, usage& other appurtenances req+B27uired to complete the work.