Public Works Department Tender

Providing laying spreading and compacting by mechanical means graded stone aggregate to wet mix macadam specification as per Table 400.12 including premixing the material with water at OMC in mechanical mix plant carriage of mixed material by tipper to site, laying in uniform layers with paver in sub-base/ base course on a well prepared surface and compacting with vibratory roller to achieve the desired density including lighting barricading and maintenance of diversion, etcetera as per MORT&H technical specification clause 406 and as per directions of Engineer- in- Charge by mechanical means including entire carriage of material in all leads , lifts. and other incidentals . The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.

Providing and laying of a strip seal expansion joint catering to maximum horizontal movement upto 70mm (seventy millimetre) complete as per approved drawing and standard specification to be installed by the manufacturer/ supplier or their authorised representative ensuring compliance to the manufacturers instructions for installation including carriage of material within all leads and lifts and other incidentals The rates are inclusive of octroi, royality, malkana ,toll tax, GST , or other taxes imposed by the Government.

Providing and applying primer coat with bitumen emulsion (SS-1) on prepared surface of granular base including cleaning of road surface and spraying primer at the rate of 0.70-1.0 kg/sqm (zero point seven zero - one point zero kilogram per squaremeter) using mechanical means as per Technical Specification Clause 502 (five hundred two ).Including all leads, lifts and carriage of materials complete as per entire satisfaction of the Engineer in charge. The rates are inclusive octrol,royality,Malkana, toll tal, or other taxes imposed by government.

Providing and fixing G.I drainage spout complete as per drawing and MORTH technical specification clause 2705 and as per the direction of Engineer-in-charge including carriage of material within all leads and lifts and other incidentals . The rates are inclusive of octroi, royality, malkana ,toll tax, GST, or other taxes imposed by the Government .

Providing and laying cement concrete 1:6:12 (one cement : six sand : twelve graded crushed/broken stone aggregate 40 mm (forty millimetre nominal size) mechanically mixed and vibrated on ground or under water and curing complete including pumping or bailing out water, dewatering removal of slush as required at site which may arise at the time of laying under water complete for all heights and depths including cost of form work in open foundation complete as per drawing and technical specification clause 802,803,1202&1203 as per direction of Engineer-in- Charge . including carriage of material within all leads and lifts and other incidentals The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government .

Excavation in earth work in hilly area in all heights and depths in all kind of soil by manual/mechanical means including saturated soil comprising of mixed soil, ordinary rock and hard rock all work of rock cutting by blasting shall be carried out by taking all necessary precautions against soil erosion, damage to hill side,water pollution, etcetra and to protect stability of hill side track shall be excavated with chiseling and wedging out rock (where blasting is prohibited). all earth work in cutting/excavation including rock excavation shallbe carried,out true tolines,grades,side slopes, width, camber super-elevation and level as shown on the drawings or as directed by the Engineer-in-Charge,in conformit with the requirement of MORD technical specification 2014 (two thousand fourteen) for Rural Road. clause 300, 1603 (three hundred, one thousand six hundred three) of General conditions for contract to achieve designed formation width including hauling and stacking of material useful for construction at suitable sites and safe disposal & dumping to be arranged by the contractor of unsuitable cut materials in specified manner,trimming,filling of unevenness,blindage and finishing of the road to specified dimensions or as directed by the Engineer -in -Charge for smooth riding. The recovery for stones,whether useful or not, for 162.02 cum(one hundred sixty two point zero two cubic metre) in all cases,@ rupees 300/- only(Rupees three hundred only) per cubic meter shall be effected on pro- rata basis. Any loss to the public and private property during the course of excavation shall be the absolute responsibility of the contractor, which shall compensated by him in all cases.The rates are inclusive octrol,royality,Malkana, toll tal, or other taxes imposed by government.

Providing and fixing 200metre(two hundred millimeter) stone (precast) re-inforced cement concrete grade M-15 (M-Fifteen) design mix minimum cement content 240kg(Two hundred forty kilogramme) per cubic metre local stone of standard design as per IRC 8 fixing in position including painting and printing etcetera. as per drawing and technical specification MORD 2014 clause 1703 including entire carriage of material with in all leads, lifts and other incidentals. The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.

Providing and fixing precast RCC railing with mechanically mixed and vibrated cement concrete of mix design to obtain minimum compressive strength of grade M-30 (M-thirty) (with graded crushed stone aggregate 12 mm(twelve millimetre nominal size) true to line and grade, tolerance of vertical RCC post not to exceed 1 in 500, centre to centre spacing between vertical post not to exceed 2000mm (two thousand millimetre) leaving adequate space between vertical post for expansion complete as per approved drawings and MORTH technical specifications clause 2703 including carriage of material within all leads and lifts and other incidentals . The rates are inclusive of octroi, royality, malkana ,toll tax,GST or other taxes imposed by the Government.

Earth work in excavation for foundation of bridge structure in all type of classification of soil comprising of ordinary rock, hard rock, chiseling/ wedging out of rocks (where blasting in prohibited ) as per drawing and MORTH technical specification clause 305.1 and as per direction of the Engineer-in- Charge including setting out, construction of shoring and bracing removal of stumps and other deleterious materials and disposal of materials upto all leads and lift, including dressing of sides and bottom including shoring and strutting and pumping , bailing out water ( surface and sub soil water) upto any depth and any quantum of water including cleaning of slush which may arise out during dewatering as per the direction of the Engineer-in- Charge including carriage of materials within all leads and lifts and other incidentals . The rates are inclusive of octroi, royality malkana ,toll tax, GST or other taxes imposed by the Government

Providing and fixing typical informatory sign board with Logo as per MORD specifications and drawing three M.S plates of 1.6mm (one point six millimetre) thick top and middle plate duly welded with M.S flat iron 25mm x 5mm (Twenty five millimetre into five millimeter) size on back on edges. The lower plate will be welded with M.S angle iron frame of 25mmx25mmx5mm (Twenty five millimetre into Twenty five millimetre into five millimetre) The angle iron frame of the lower post plate and flat iron frame of middle plate will be welded to 2Nos (two numbers ) 75x75mm (seventy five into seventy five millimeter) of 12 (twelve ) SWG sheet tubes posts duly embedded in cement concrete M-15 (M-Fifteen) grade blocks of 450x450x600mm( Four hundred fifty into Four hundred fifty into Six hundred millimetre ) 600mm(six hundred millimeter) below ground level. Two top most diamond plate will be welded to middle plate by 47mmx47mm (forty seven millimeter into seventy seven millimeter) of 12 (twelve) SWG steel plate tube. All M.S will be stove enameled on both sides. Lettering and printing arrows border etcetera. will be painted with ready mixed synthetic enamel paint of superior quality in required shade and colour . All sections of framed posts and steel tube will be painted with primer and two coat of epoxy paint as per drawing and technical specification clause 1701 and annexure 1700.1 including entire carriage of material with in all leads,lifts and other incidentals. The rates are inclusive of octroi, royality , GST or other taxes imposed by the Government .

Providing and fixing boundry pillar/ local stone in re-inforced cement concrete M-15 (M-Fifteen) grade design mix minium cement content 240kg(Two hundred forty kilogramme) per cubic metre local stone of standard design as per IRC 25, fixing in position including finishing and lettering but excluding painting etcetera as per drawing and Technical specification MORD 2014 clause 1704 including entire carriage of material with in all leads , lifts and other incidentals. The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.

Providing and fixing of semi –reflective cautionary, mandatory and informatory sign board as per IRC-67 as per MORD specifications 2014 and drawing of 1.5mm (one point five millimetre) thick mild steel sheet duly stove white colour in front and gray colour on back with red reflective border of 65mm (sixty five millimetre) width and required letters and figures with reflective tape engineering grade as per clause 1701.3.9 for rural road of required grade and colour supported and welded on 47x47mm (forty seven into forty seven millimetre) of 12 (twleve) SWG sheet tubes firmly fixed to be ground by meant of properly designed foundation with in cement concrete M-15 (M-Fifteen) grade design mix minimum cement content 240kg(Two hundred forty kilogramme) per cubic metre blocks of 450x450x600mm (Four hundred fifty into Four hundred fifty into Six hundred millimetre ) 600mm(six hundred millimeter) below ground level as per approved drawing clause 1701.2.2 800mm x 600 mm (eight hundred millimetre into six hundred millimetre) rectangular including entire carriage of material with in all leads, lifts and other incidentals. The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.

Providing and laying filter media with granular material /crushed aggregates satisfying the requirements laid down in of MoRTH specification to a thickness of not less than 600mm( six hundred millimetre )with smaller size towards the soil and bigger size towards the wall and provided over the entire surface behind abutment , wing wall and return wall to the full height, compacted to a firm condition complete as per drawing and technical specification including entire carriage of materials within all leads and lifts and other incidentals . The rates are inclusive of octroi, royality, malkana ,toll tax , GST, or other taxes imposed by the Government.

Providing and fixing ordinary kilometre stone precast re-inforced cement concrete M-15 (M-Fifteen) grade design mix minium cement content 240kg (Two hundred forty kilogramme) per cubic metre kilometre stone of standard design as per IRC 8, fixing in position including painting and printing etcetera as per drawing and Technical specification MORD 2014 clause 1703 including entire carriage of material with in all leads , lifts and other incidentals. The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.

Providing and laying of boulder apron laid in wire crates with 4 mm (four millimetre) dia Galvanised Iron wire conforming to IS:280 and IS:4826 in 100 mm x 100 mm (hundred into hundred millimetre) mesh (woven diagonally) including 10 (ten) per cent extra for laps and joints laid with stone boulders weighing not less than 25 kg(twenty five kilograme) each as per drawing and MORT&H technical specifications Clause 2503 and as per directions of Engineer- in- Charge including entire carriage of material within all leads , lifts and other incidentals. The rates are inclusive of octroi, royality, malkana ,toll tax GST, or other taxes imposed by the Government.

Providing weep holes in brick masonry / stone masonry /plain and reinforced concrete abutment , wing wall ,return wall with 100mm (one hundred millimetre) dia AC pipe extending through the full width of the structures with slope of 1(V):20(H) towards drawing face complete as per drawing and MORTH technical specification clause 2706 & 2200 including entire carriage of material within all leads and lifts and other incidentals. The rates are inclusive of octroi, royality malkana ,toll tax , GST or other taxes imposed by the Government

Back filling behind abutment, wing wall and return wall with Granular material complete as per drawings and Technical Specification Clause 1204.3.8 (one thousand two hundred four point three point eight) and as per the direction of the Engineer-in-Charge including carriage of material through all modes of transportation within all leads and lifts and other incidentals.The rates are inclusive octrol,royality,Malkana, toll tal, or other taxes imposed by government.

Supplying ,fitting and placing HYSD bar made of Tata Toscon, Sail reinforcement in sub structure in all heights including cost of bending binding wire and cost for cutting straightening bending and placing in position of bars complete as per drawings and MORTH technical specification clause 1600 & 2200 including entire carriage of material within all leads and lifts and other incidentals . The rates are inclusive of octroi, royality malkana ,toll tax ,GST or other taxes imposed by the Government

Supplying ,fitting and placing HYSD bar reinforcement made of Tata Tiscon / Sail in super structure in all heights including cost of binding wire and cost for cutting binding and placing in position of bars complete as per drawings and MORTH technical specification Clause 1600 including carriage of material within all leads and lifts and other incidentals . The rates are inclusive of octroi, royality, malkana ,toll tax GST, or other taxes imposed by the Government.

Construction of granular sub base by providing well graded material mixing in a mechanical mix plant at OMC carriage of mixed material to work site upto all leads spreading in uniform layers with motor grader on prepared surface and compacted with three wheel 80-100 kn static roller to achieve the desired density, complete as per technical Specification Clause 402 for grading –I material and as per direction of Engineer-in- Charge including entire carriage of material with in all leads and lifts and other incidentals . The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated cement concrete of mix design to obtain minimum compressive strength of grade M-30 (M-Thirty ) with graded crushed stone aggregate 20 mm twenty millimetre) nominal size including cost of form work, curing and reinforcement for wearing coat complete as per drawing and MORD technical specification clause 800 & 1404 including carriage of material within all leads and lifts and other incidentals . The rates are inclusive of octroi, royality, malkana ,toll tax , GST , or other taxes imposed by the Government .

Providing , furnishing and placing reinforced / Prestressed cement concrete design mix to obtain minimum compressive strength M-30 (M-Thirty ) in deck slab as per drawing and MORTH technical specification clause 1500, 1600 & 1700 above 10 (ten) metre height by using batching plant transit mixer and concrete pump including cost of form work and curing complete including carriage of material within all leads and lifts and other incidentals . The rates are inclusive of octroi, royality, malkana ,toll tax GST , or other taxes imposed by the Government

Providing , furnishing and placing reinforced / Prestressed cement concrete design mix to obtain minimum compressive strength of grade M-30 (M-thirty ) in super structure (Kerb) as per drawing and MORTH technical specification clause 1500, 1600 & 1700 above 10 (ten) metre height by using batching plant transit mixer and concrete pump including cost of form work and curing complete including carriage of material within all leads and lifts and other incidentals . The rates are inclusive of octroi, royality, malkana ,toll tax , GST , or other taxes imposed by the Government .

Providing and laying Reinforced concerte pipe NP2 900mm(nine hundred millimetre ) dia for culverts on first class bedding of granular material in single row including providing and fixing collar with cement mortar 1:2(one cement : two sand ) but excluding excavation protection work back filling concrete and masonry work in head walls and parapets Clause 1108, and as per direction of Engineer-in- Charge including entire carriage of material with in all leads and lifts and other incidentals . The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.

Supplying, fitting and fixing in position true to line and level POT-PTFE bearing consisting of a metal piston supported by a disc or un-reinforced elastomer confined within a metal cylinder, sealing rings, dust seals. PTFE surface sliding against stainless steel mating surface , complete assembly to be of cost steel/ fabricated structural steel, metal and elastomer elements to be as per IRC:83 part-I &II respectively and other parts conforming to BS: 5400 section 9.1&9.2 and clause 2006 of MORTH specification complete as per drawing and approved technical specifications including entire carriage of material in all leads and lifts and other incidental . The rates are inclusive of octroi, royality, malkana ,toll tax, GST , or other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated cement concrete nominal mix 1:3:6 (one cement :three Sand :six graded crushed stone aggregate 40mm (forty millimetre nominal size) on ground or under water and curing complete including pumping or bailing out water, dewatering removal of shush as required at site which may arise at the time of laying under water complete for all heights and depths including cost of form work for plain concrete in abutment foundations for all types of structures complete as per drawing and MORTH technical specifications clause 2100 and as per direction of Engineer-in- Charge including entire carriage of material within all leads and lifts and other incidentals . The rates are inclusive of octroi, royality malkana ,toll tax, GST or other taxes imposed by the Government

Providing and applying tack coat with Bitumen emulsion (RS-1) using emulsion distributor at the rate of 0.25 to 0.30 kg/sqm (zero point two five to zero point three zero kilogram per square meter ) on the prepared granular surfaces treated with primer & cleaned with Hydraulic broom as per Technical Specification Clause 503 (five hundred three). Including all leads, lifts and carriage of materials complete as per entire satisfaction of the Engineer in charge. The rates are inclusive octrol,royality,Malkana, toll tal, or other taxes imposed by government.

Surface dressing on new surface with paving bitumen of grade VG- 10 (viscosity grade ten) of approved quality using 2.25 kg (two point two five kilogram) of bitumen per sqm with 1.65 cum (one point sixty five cubic metre) of stone chippings 13.2mm (thirteen point two millimetre) nominal size per 100 sqm (one hundred square metre) of road surface, including consolidation with road roller of 6 to 8 (six to eight) tonne capacity etcetra complete and as per direction of Engineer-in- Charge including entire carriage of material with in all leads and lifts and other incidentals . The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated reinforced Cement Concrete design mix to obtain minimum compressive strength of grade M-35(M- thirty five) including cost of form work, reinforcement and curing complete in approach slab as per drawing and MORTH technical specification clause 1500, 1600 ,1700& 2704 as per the direction of Engineer-in –charge. including carriage of material within all leads and lifts and other incidentals . The rates are inclusive of octroi, royality, malkana ,toll tax, GST, or other taxes imposed by the Government.

Construction of sub grade and earthen shoulders with approved material obtained from borrow pits with all lifts and leads, transporting to site spreading , grading to required slope and compacted to meet requirement of Table 300.2 upto any leads and lifts as per MORT&H Technical specification Clause 303.1 and as per directions of Engineer- in- Charge including entire carriage of material within all leads, lifts and other incidentals . The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated plain Cement Concrete design mix to obtain minimum compressive strength of grad M-15 (M- fifteen ) including cost of form work, and curing complete in substructure on ground or under water and curing complete including form work with the M.S plate , including pumping or bailing out water, dewatering removal of slush as required at site which may arise at the time of laying under water complete for all heights and depths as per drawing and MORD technical specification clause 802,804,805,806,807,1202 &1204 and as per the direction of Engineer-in –charge. including carriage of material within all leads and lifts and other incidentals . The rates are inclusive of octroi, royality malkana ,toll tax, GST or other taxes imposed by the Government

Providing and laying mechanically mixed and vibrated plain / reinforced M-10 (M-ten) design mix cement concrete on ground or under water and curing complete including pumping or bailing out water, dewatering removal of shush as required at site which may arise at the time of laying under water complete for all heights and depths including cost of form work for plain concrete in open foundation for all types of structures complete as per drawing and technical specifications clause 802,803, 1202 &1203 and as per direction of Engineer-in- Charge including entire carriage of material with in all leads and lifts and other incidentals . The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.

Back filling behind abutment wing wall and return wall with granular material complete as per drawing and MORD technical specification clause 1204.3.8 and as per direction of Engineer- in Charge including carriage of material within all leads and lifts and other incidentals .The rates are inclusive of octroi, royalit, malkana ,toll tax , GST, or other taxes imposed by the Government .

Providing and laying mechanically mixed and vibrated /plain /reinforced cement concrete design mix to obtain minimum compressive strength of grade M-30 (M-Thirty ) in sub structure foundation using minimum cement contents of 405kg(four hundred five kilogram) per cubic metre with 20mm(twenty millimetre) nominal size crushed stone aggregate in abutment , bed block and dirt wall upto any heights including cost of form work and curing complete including pumping or bailing out water, dewatering removal of slush as required at site which may arise at the time of laying under water complete for all heights and depths as per drawing and MORTH technical specification clause 1500,1700&2200 including carriage of material within all leads and lifts and other incidentals . The rates are inclusive of octroi, royality, malkana ,toll tax, GST or other taxes imposed by the Government

Providing and laying mechanically mixed cement concrete 1:5:10 (one cement : Five sand : ten graded crushed / broken stone aggregate 40mm (forty millimetre nominal size) and curing complete including the cost of form work with M.S plates for plain concrete on ground or under water and curing complete including pumping or bailing out water, dewatering removal of slush as required at site which may arise at the time of laying under water complete for all heights and depths in retaining walls / breast walls as per drawing and MORD technical specifications section 802,803, 1202 and 1203 and as per direction of Engineer-in- Charge including entire carriage of material with in all leads and lifts and other incidentals . The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.

Providing and laying mechanically mixed and vibrated plain /reinforced Cement Concrete design mix to obtain minimum compressive strength of M-15 (M- fifteen ) grade with broken/ crushed aggregate 40mm (fouty millimetre) nominal size having minimum contents not less than 275 kg (two hundred seventy five kilograme) per cubic metre including cost of form work, and curing complete for 14 (fourteen) days in sub structure on ground or under water and curing complete including form work with the Mild Steel Plate , including pumping or bailing out water, dewatering removal of slush as required at site which may arise at the time of laying under water complete for all heights and depths as per drawing and MORT&H technical specification clause 802, 804, 805, 806,807,1202 and 1204 and as per the directions of Engineer-in –charge including carriage of material within all leads and lifts and other incidentals . The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.

Providing and laying flooring laid over cement concrete bedding complete as per drawing and technical specification Clause 1303 rubble stone laid in cement mortar 1:3 ( one cement : three coarse sand ) and as per direction of Engineer-in- Charge including entire carriage of material with in all leads and lifts and other incidentals . The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.

Providing and fixing of semi –reflective cautionary, mandatory and informatory sign board as per IRC-67 as per MORD specifications 2014 and drawing of 1.5mm (one point five millimetre) thick mild steel sheet duly stove white colour in front and gray colour on back with red reflective border of 65mm (sixty five millimetre) width and required letters and figures with reflective tape engineering grade as per clause 1701.3.9 for rural road of required grade and colour supported and welded on 47x47mm (forty seven into forty seven millimetre) of 12 (twelve) SWG sheet tubes firmly fixed to be ground by meant of properly designed foundation with in cement concrete M-15 (M-Fifteen) grade design mix minimum cement content 240kg (Two hundred forty kilogramme) per cubic metre blocks of 450x450x600mm ( Four hundred fifty into Four hundred fifty into Six hundred millimetre ) 600mm(six hundred millimeter) below ground level as per approved drawing. clause 1701.2.2 traffic sign 600mm (six hundred millimetre) equilateral triangle including entire carriage of material with in all leads, lifts and other incidentals. The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.

Earth work in excavation for all type of road structure such as reteaining walls, breast walls, culverts, drains and parapets etcetra in all type of classification of soil comprising of ordinary soil , ordinary rocks, hard rocks, chiselling/ wedging out of rocks ( where blasting is prohibited) as per drawings and technical specification MORD2014. Clause 305 (three hundred five) and as per direction of the Engineer-In -Charge including setting out construction of shoring and bracing, removal of stumps and other deleterious materials and disposal of materials upto all leads and lifts including dressing of sides and bottom and back filling in trenches with excavated suitable approved materials to the original surface in layers not exceeding 150mm ( one hundred fifty milimetres) compacted thickness including shorting and strutting and pumping and bailing out water (surface and sub soil water) upto all depth and any quantum of water including cleaning of slush which may arise out during dewatering and as per the direction of the Engineer-in-Charge including carriage of material through all modes of transportation within all leads and lifts and other incidentals.The rates are inclusive octrol,royality,Malkana, toll tal, GST or other taxes imposed by government.

Providing and laying cement concrete 1:4:8 (one cement : four sand : eight graded crushed/broken stone aggregate 40 mm (forty millimetre nominal size) mechanically mixed and vibrated on ground or under water and curing complete including pumping or bailing out water, dewatering removal of shush as required at site which may arise at the time of laying under water complete for all heights and depths including cost of form work in open foundation complete as per drawing and technical specification clause 802,803,1202&1203 as per direction of Engineer-in- Charge including entire carriage of material within all leads lifts and other incidentals. The rates are inclusive octroi , royality , Malkana, toll tax, GST or other taxes imposed by the Government.