Haryana Urban Development Authority Tender

Supply,Installation,Testing & Commissioning of Zinc-plated steel to Support Valve Battery fitted for Filters, Height 2.30m. (Reqired 2 nos). Each filter complete as per technical specification & conditions attached. Make : Haywards / Kripsol / Tanishq Ions / Aqua Whizz

5/ Supplying, laying, testing and commissioning of following media for filters complete as per technical specification & conditions attached. 5.01 Quartz sand of following sizes : 4-8 mesh : 2000 kg 8-16 mesh : 10000 kg 16-24/32 mesh : 3000 kg

5.02 Gravel 1-2 mm

6/Supply,Installation,Testing & Commissioning of 10 HP monoblock recirculation pump with cast iron body, bronze impeller to be operated on 415V. 3 phase AC supply and suitable for the discharge of 120-125 m3/hr of water flow at ahead of 12m with base frame, pressure guage, SS strainer including foundation and other accessories. Make : Astral / Kripsol / Aqua Whizz /Aqua Itlay / Pentair/Grundfos 5 Nos. @ Rs.332183.20 Each

7/Supply, Installation,Testing & Commissioning of following size of electronic membrane dosing pumps (IP-65 protection) floor/wall mounted suitable for operation on 220 V, 50Hz with a flow rate of 20 litre per hour at pressure of 5 bar with transparent polycarbonate protection for operation panel complete as per technical specification & conditions attached.

8/Supply,Installation,Testing & Commissioning of Semi transparent polyethylene tank, capacity of tank 500 ltrs. Complete as per technical specification & conditions attached.

9/Supply, Installation, Testing & Commissioning of the following size of uPVC (Unplasticised Polyvinylchloride) butterfly valve/ball valves (Level Operated) suitable for 10 kg per sq cm pressure with EPDM seat, nuts, bolts, washer etc. complete as per technical specification & conditions attached. Make : Astral / Kripsol / Tanishq Ions / Aqua Whizz 9.01 Supply, Installation, Testing & Commissioning of Butterfly Valve dia 160mm.

9.02 Supply, Installation, Testing & Commissioning of Butterfly Valve dia 110mm.

9.03 Supply, Installation, Testing & Commissioning of 63 mm Butterfly / Ball Valve including flane adaptor and nut bolts

9.04 Supply, Installation, Testing & Commissioning of Wafer Check Valve dia 160mm.

10 Supply, Installation, Testing and Commissioning of Flange-Adaptor for 160 mm complete as per technical conditions attached. Make : Kripsol / Tanishq Ions / Aqua Whizz /Aqua Itlay

11/ Supply, Installation, Testing and Commissioning of Flange and Adaptor for 110 mm complete as per technical conditions attached. Make : Kripsol / Tanishq Ions / Aqua Whizz / Aqua Itlay

12/ Supply, Installation, Testing and Commissioning of the following size of uPVC ( Unplasticised Polyvinylchloride) pipes with minimum 10 kg/cm2 pressure including required size of fittings i.e. coupler, tees, bends, flanges, complete as per technical specification & conditions attached. Make : Astral / Supreme / Prince / Finolex 12.01 63 mm dia 36 Mtr @ Rs.443.40 Per Mtr

12.02 110 mm dia

12.03 150 mm dia

12.04) 315 mm dia - Delivery and suction header Line for pump and filter input and output incl all flanges, fittigns and nutbolts. Make : Kripsol / Tanishq Ions / Aqua Whizz 12.7.2.1 35 mm thick shutters

LT CABLE 24.2.2 Laying of underground cable 0. 75 metre below ground level covered with sand and bricks including excavation and refilling of trenches.:- 24.2.2.1 2.5 Sq mm to 10 Sq mm 2 to 4 Core

14/24.1 EARTHING AND LIGHTENING ARRESTOR 24.1.12 Supplying and laying 6 S.W.G G.I. wire at 0.50 m below ground level from earth electrode including thimbles, soldering etc. as required.

15/Supply, Installation, Testing & Commissioning of cubical type L.T. Panels for 415 V, 3 phase, 4 wire, 50 Hz, AC supply system fabricated in compartmentalized design from CRCA MS sheet of 2/1.6mm thick, IP 42 Protection, 3 mm thick for gland plates i.e cleaning and finishing complete with 7 tank process for conductivity, DMC/SMC bus bar supports with Short Circuit withstand capacity of 31 MVA for 1 Sec., bottom base channel of MS section not less than 100 mm x 50mm x 5mm thick, fabrication shall be done in transportable sections, entire panel shall have acommon copper earth bar size 25 mm x5 mm at the rear with 2 nos. earth studs, solid connections from main bus bar to switchgears with reqiured size of aluminum bus bar and control wiring with 2.5 sq. mm/1.5 sq.mm FRLS PVC insulated copper conductor S/C cable, cable alleys, cable gland plates in two half, including providing following switchgears ( All MCCBs shall be fixing dcomplete as per technical specificaiton & conditions attached. Make : Advance Panel / Elescon Eng / Adelac / Aqua Whizz / L&T

15.01 INCDOMING i) 1 No. 125 A, 35 KA, 415 V, FP MCCB ( micro process based with E/F, O/C & S/C) ii) 1 No. (0-400 A) Digital Ammeter and Selector Switch alongwith current transformers iii) Phase indicating lamps (1 Set) iv) 1 No. (0-500 V) Digital voltmeter and Selector Switch 15.02 BUS BAR i) 1 seT OF 400 a, 415 v tpn Aluminium Bus Bar 15.3 OUT GOINING 1) 5 NO. 63 A, 25 KA, TPN MCCB (For Recirculating Pumps) and Star/Delta Starters Suitable for Motor. ii) 4 No. ( including one standby), 32 A, 10 KA, TP MCB (For Chlorine Pumps) mand Dol Starters Suitable for Motor.

16/23.23 MISCELLANEOUS 23.23.7 Supply and erection of cable tray cover made of 1.25 mm thick GI sheet asrequired including erection of the same on existing cable tray with necessary fixture and other material required to complete the job in all respect up to the entire satisfaction of Engineer-in Charge of the work 23.23.7.3 GI cable tray Cover , suitable for cable tray of 375 X 50 X 2 mm

17/SITC of 2 HP Submersible pumps with following specification. Outlet size 50 mm, 2 HP, 1.5 k/w 2900 RPM, solid handling capacity 23mm head range with connection testing complete as per technical specification & conditons attached. To piming the pumps. Make : Kirloskar / Modi / Crompton / Astral / Jhonson

18) SITC of Suction Sweeper set and other cleaning agents including the followings : Self Priming Pump set of 2 HP of make Astral / Aqua Whizz / Tanishq-Ions/Aqua Itlay/Kripsol with attached Hair Strainer to prevent the leaves and other derbis. Cartridge Filter CF-150 with inlet and outlet union ; to be installed on the trolley SS-304 Trolley - heavy duty with four wheels and other attahcment for the suction items Suction head SS-304 : 900x200x150mm with 2 nos of brushes with PVC bristles Rope of 20mm thick; nylon material; 150 meter length Telescopic pole : 4.8 meter : 02 nos Leaf Net : Deep bag type : 01 no Leaf net : flat type 01 no Side brush : 01 no with pvc bristles Algae brush : with SS bristles Testing Kit : 01 no

19) SITC of Over Flow Grating of 295mm Modular Curvable overflow gratings Modular gratings for curves snaps together on central spine allowing for flexibility between tiles. [45 Units per meter],Ht 35,width 295mm. Make: Tanishq-Ions, Tanishq-Ions Code : 00222